Home
SATO
Printer
LP 100R
Page 129
SATO LP 100R - Page 129
354 pages
Manual
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
LP 100R Laser Printer Operator's Guid
e
Chapter 6: Supervisory Functions
Rev: 1
Page 6-15
April, 2014
of 128 pages
When the page has printed, press
Feed
until the
printed
page is
complete
ly
ejected from the printer.
Figure 6-9. Font Sampler page.
128
130
Table of Contents
Main Page
Default Chapter
3
Table of Contents
3
Chapter 1: General Information
11
Notice
12
Trademarks
12
Liability Disclaimer
13
Regulatory Notices
14
FCC Regulations
14
Manufacturer's Instructions
15
User's Responsibility
15
DHHS (Department of Health and Human Services)
16
CDRH (Center of Devices and Radiological Health) Regulations
16
Chapter 2: Printer Components
17
Overview
18
Printer Components: Left-Side Front - View One
19
Transfer Unit Cleaning Rod
20
Main Charger Unit Cleaning Rod
20
Top Panel Switches
20
Top Panel Switch LED Functions
21
Emergency Power Switch
22
Fuser Unit
22
Burster Unit (Optional Component)
22
Side Panel Switches
22
METO-Logic Controller
22
Printer Components: Left-Side Front - View Two
23
Front Door
24
Toner Bottle Access Cover
24
EP Holder
24
Touch Display Unit (TDU)
24
Toner Bottle
24
Page Counter
25
Service Cover
25
Left-Side Door
25
Toner Fuser Filter
25
Swing Guide (Optional Component)
25
Removable Stacker Table
25
Adjustable Foot
25
Waste Toner Collecting Bottle
25
Main Charger Unit
26
OPC Cartridge
26
Developer Unit
26
Printer Components: Right-Side Rear View
27
Tractor Width Knob
27
Load Switch
27
Tractor Raise Lever
27
Form End Sensor
27
Tractor Unit
27
Suction Brake Unit
28
Right Edge Forms Guide
28
Web Guide
28
Main Circuit Breaker
28
Chapter 3: Printer Operation
29
Overview
30
End-User License Agreement
31
Power up and down Procedures
32
Power up Procedures
33
Power down Procedures
34
Emergency Power down
34
Normal Power down
34
Operator Responsibilities
35
Supervisor Responsibilities
36
Appendix A: Installing System Software
36
Appendix B: Managing Files
36
System Start-Up Procedures
38
System Start-Up Screen Definitions
39
Menu System
42
Main Menu
42
Main Menu Buttons
42
Main Menu Options
43
Exit Menu System Buttons
44
Exit Menu System Options
44
Advanced Menu
45
Service Menu
45
Supervisor Menu
45
Operator Express Menu
46
Operator Express Menu Buttons
46
Recall Configurations
47
Recall Configurations Menu Buttons
47
Horizontal Fine Adjustment Menu Buttons
48
Modify Horizontal Fine Adjustment
48
Modify Vertical Fine Adjustment
49
Vertical Fine Adjustment Menu Buttons
49
Print Configurations
50
Print Time & Usage Report
52
Print Status Page
54
Printer Cleaned
56
Page Flush
57
Document Loading Procedures
58
Chapter 4: Printer Maintenance
62
Maintenance
62
Cleaning Tools
62
Life and Cleaning Interval
63
Changing Consumables
63
Toner Removal
63
Fuser Unit Cleaning
64
Charger Cleaning
65
AIDC Sensor Cleaning
67
Daily Maintenance
70
AIDC Sensor Cleaning
70
Tractor Unit Cleaning
70
Fusing Unit Cleaning
70
User-Replaceable Consumables
71
Expected Life of User-Replaceable Consumables
72
Touch Display Unit
73
Printer Consumable Supplies
74
Toner Bottle Replacement
75
Waste Toner Collecting Bottle Replacement
77
OPC Drum/Opc Cartridge Replacement
78
Cleaning Blade Replacement
81
Chapter 5: Problem Solving
85
Introduction
86
Audible Alarm
87
Safety Considerations
87
Paper Jams
88
Paper Jams - General
88
Paper Jams - in the Tractor Unit
89
Paper Jams - at the Fusing and Exit Areas
91
Interlock Errors
95
Print Quality Problems
96
Blank Print
96
Black Print
96
Light Image
97
Dark Image
97
Background Haze
98
Black Stripe
98
Black Specks
98
White Stripe
99
Print Voids
99
Uneven Image Density
100
Warning Messages
101
Error Messages Requiring Operator Intervention
102
Printer Hardware Messages
104
Controller Errors
106
Communication Errors
106
Emulation Errors
107
Kodescript™ Errors
107
Kodescriptplus Status and Error Codes
108
Codes 01-15
108
Codes 16-50
108
Codes 51-80
108
Codes 81-99
108
Kodescriptplus™ Status and Error Codes
108
Kodescriptplus Status Messages
109
Kodescriptplus Warnings
110
Kodescriptplus Errors
112
Kodescriptplus Fatal Errors
114
Chapter 6: Supervisory Functions
115
Introduction
118
Supervisor Menu
119
Supervisor Menu Access
119
Test Prints Function
123
Test Prints Function Access
123
Grid Pattern
124
Character Fill
126
Font Sampler
128
Placement Test
130
Page Coverage
132
User Files
135
Font Detail
137
Interface Setup Function
139
Interface Setup Function Access
139
RS-232 Interface
140
Parallel Interface
140
Busy Req
140
Enable/Disable
140
Strobe
140
Parallel Interface Data Transfer Rate Modification
141
Reset Settings
141
Ta, Tb, and Tc
141
Ethernet Setup
142
Enable Ethernet (Enable/Disable Ethernet)
143
Enable/Disable Ethernet
143
Activate New Settings
144
Host Protocol
144
Job Trace Enable/Disable
145
Raw Printing (TCP/IP Setup)
145
Windows Network Printing - Enable/Disable
145
Configuration Function
145
Files Function
146
Files Function Access
146
Reset Function
147
Reset Function Access
147
Cancel Job on Jam Function
148
Cancel Job on Jam Function Access
148
Disabled/Enabled (Cancel Job on Jam)
149
Prompt (Cancel Job on Jam)
150
Cancel Job on Field Error Function
151
Cancel Job on Field Error Function Access
151
Disabled/Enabled (Cancel Job on Field Error)
151
Prompt (Cancel Job on Field Error)
152
Password Enable Function
153
Password Enable Function Access
153
Change Password Function
154
Change Password Function Access
154
Time Function
156
Time Function Access
156
System Time
158
Up-Time
159
Set Time
160
Set Time Zone
162
Standard Time Zones
163
Daylight Saving
164
Network Time Setting Function
166
Network Time Setting Function Access
166
Network Time Enable (Select Local System Time)
167
Network Time Enable (Select Server Time)
168
Time Server (Enter/Change Time Server IP Address)
169
Configuration Procedures
171
Configuration Introduction
171
Printer Start-Up
171
Modifying or Creating a New Configuration
171
Status Page
172
Stored and Default Configuration
173
Configuration Function Menu
174
Configuration Function Menu Access
174
Recall Configuration
175
Store Configuration
177
Remove Configuration
180
Edit
182
Printer Setup Menu
183
Printer Setup Menu Access
183
Form Height
185
Print Width
187
Lines Per Inch
189
Characters Per Inch
191
Vertical Adjustment
193
When a Print Job Is in Progress
193
When the Printer Is Idle
196
Horizontal Adjustment
197
When a Print Job Is in Progress
197
When the Printer Is Idle
200
Image Density
201
Material Type
203
Orientation
205
Emulation
207
Primary Font
209
Auxiliary Font
211
Symbol Set
213
Line Termination
215
Error Recovery
217
Emulation Settings
219
Kodescriptplus
220
Pcl5E Options
222
Page Buffer Limit
224
Resolution
226
EAS (Electronic Article Surveillance)
228
Swing Mode (Optional Unit)
230
Reverse Mode
232
Burster Mode (Optional Component)
234
Roll to Roll Mode
236
Paper Suction
237
Energy Fusion
239
AIDC Mode
241
Appendix A: Installing System Software
243
Introduction
244
Copying the Operating System
244
System Program - Full Installation
245
System Program - Software Upgrade
248
Appendix B: Managing Files
253
Introduction
254
Managing Fonts, Logos, and Formats
255
Managing User's Fonts
256
Procedures
256
Functional Capability
258
USB to Active
259
Active to USB
263
Delete Active
265
Manage Archive
267
Functional Capability
267
To Active
268
To Archive
270
USB to Archive
272
Archive to USB
275
Delete Archive
277
System Program
279
Installing the System Program
279
Copying the System Program
282
System Menu
285
Installing the Updated System Menu
285
Copying the Updated System Menu
288
User's Configuration File
291
Installing the Updated User's Configuration File
291
Copying the Updated User's Configuration File
294
System Setup File
297
Installing the Updated System Setup File
297
Copying the Updated System Setup File
300
System Error Log
303
Installing the System Error Log
303
Copying the System Error Log
306
Capturing a File to Flash Drive
309
Appendix C: Service/Technical Support
313
Service
313
Technical Support
314
Appendix D: Ordering Supplies
315
Ordering
315
Supplies
315
Available Supplies
315
Appendix E: the Menu System
318
Main Menu
318
Operator Express Menu
318
Operator Express Menu
319
Supervisor Menu
320
Configuration
320
Printer Setup
321
Emulation Settings - Kodeplus
321
Configuration
321
Printer Setup
322
Emulation Settings - Kodeplus
324
Emulation Settings - Pcl5E
324
Emulation Settings - IPDS
324
Emulation Settings IGP/VGL
325
Emulation Settings - IGP/PGL
326
Emulation Settings Pcl5E
327
Emulation Settings IPDS
328
Interface Setup
330
Parallel Setup
330
Ethernet Setup
330
Parallel Setup
331
Ethernet Setup
332
Files
333
Service Menu
334
Shortcut Keys
335
Appendix F: Product Specifications
338
Print Method
338
Print Speed
338
Print Resolution
338
Interfaces
338
Emulations
338
Document Width
339
Document Length
339
Print Area
339
Maximum Ejection Size
339
Document Thickness
339
Hopper Capacity
339
Stacker Capacity
339
Image Density
339
Fusing Method
339
Environmental Temperature
339
Input Voltage
340
Dimensions
340
Weight
340
User Features
340
File Management
340
Printer Options
340
Appendix G: Operating/Environ. Requirements
342
Space Requirements
342
Power Requirements
343
Power Source
343
Temperature/Relative Humidity
343
Operating Conditions
344
Precautions When Operating the Printer
345
Moving the Printer
345
Appendix G: Operating/Environmental Requirements
342
Appendix H: Default Passwords
347
Default Passwords
348
Appendix I: End-User License Agreement
349
End-User License Agreement for SATO Controller Software
350
Other manuals for SATO LP 100R
Installation Guide
80 pages
Related product manuals
SATO CT4-LX
564 pages
SATO LM412e
29 pages
SATO LC400e Series
255 pages
SATO CL4NX
807 pages
SATO CL408
249 pages
SATO GL408e
35 pages
SATO S84 ex
124 pages
SATO CL412e
288 pages
SATO CG408TT
102 pages
SATO WS408TT
135 pages
SATO CL4NX Plus
801 pages
SATO CL408e/412e
14 pages
To Next Page
Loading...
