Mazda Mazda6 - Page 149

TROUBLESHOOTING
F1–61
F1
End Of Sie
X: Applicable
Possible factor
Troubleshooting item
IAT sensor and related circuit malfunction Barometric pressure sensor malfunction Neutral or clutch switch and related circuit malfunction (MTX) MAF sensor and related circuit malfunction Knock sensor and related circuit malfunction TP sensor and related circuit malfunction TP sensor misadjustment (including looseness) P/S pressure switch and related circuit malfunction Improper refrigerant charging amount A/C relay (A/C control signal circuit malfunction A/C compressor magnetic clutch malfunction Condenser fan system malfunction Improper load signal input Clutch slippage ATX related parts malfunction VSS and related circuit malfunction Improper ATF level Brake dragging Loose parts Improper balance of wheels and tires Drive line malfunction Suspension malfunction PATS operating (if equipped)
1 Melting of main or other fuses
2 MIL illuminates x x x x x x x x
3 Will not crank x
4 Hard to start/long crank/erratic
start/erratic crank
x
5 Engine stalls. After start/at idle x x x x
6 Cranks normally but will not start x
7 Slow return to idle
8 Engine runs rough/rolling idle x x x x x x
9 Fast idle/runs on x
10 Low idle/stalls during deceleration x x x x x x
En
g
ine stalls/
q
uits
.
Acceleration/cruis
e
x x xx xx xxx
En
g
ine runs rou
g
h. Acceleration/cruis
e
x x xx xx xxx
Misses Acceleration/cruis
e
x xx xx xxx
Buck/jerk Acceleration/cruise
/deceleration
x xx xx xxx
Hesitation/stumble Acceleration x x x x x x x x x
11
Surges Acceleration/cruise x x x x x x x x
12 Lack/loss of power Acceleration/cruise x x x x x x x x
13 Knocking/pinging Acceleration/cruise x x x
14 Poor fuel economy x x x x x
15 Emission compliance x
16 High oil consumption/leakage
17 Cooling system
concerns
Overheating x x x
18 Cooling system
concerns
Runs cold x
19 Exhaust smoke
20 Fuel odor (in engine compartment)
21 Engine noise x
22 Vibration concerns (engine) xxxx
23 A/C does not work sufficiently. x x x
24 A/C is alwa
y
s on or A/C compresso
r
runs continuously.
xx
25 A/C is not cut off under WOT conditions x x
26 Exhaust sulfur smell
27 Constant voltage x x x x x x
28 Spark plug condition x x
29 ATX concerns Upshift/downshift/e
ngagement
See Section K, TROUBLESHOOTING
A6E39802004