ELECTRICAL SYSTEM (see also Section M)
Trouble Cause Remedy
Spark plug fouls 1. Dirty air lter Clean
easily 2. Worn piston rings Replace
3. Worn piston or cylinder liner Replace
Spark plug electrodes 1. Spark plug electrode gap too close Adjust
overheat 2. Heat rating too high Replace with recommended
spark plug
Generator does not charge or 1.
Cables running to voltage regulator improperly connected or
Connect correctly or
is not providing enough charge shorted replace
2. Voltage regulator faulty Replace
3. Generator coil faulty Replace
Generator overcharges battery 1. Voltage regulator faulty Replace
Battery does not hold charge 1. Battery terminals dirty Clean
Starter motor 1. Battery is at Charge
does not start or slips 2. Control on R.H. switch faulty Replace
3. Starter relay faulty Replace
4. Starter motor faulty Repair or replace
5. Worn starter gears Replace
6. Worn or damaged freewheel rollers Replace freewheel
INJECTION FUEL FEEDING SYSTEM (See Section S)
To Next Page
Loading...
