PA1553
10
DISTANCE TRAVELED
1
(miles/km)
LUBRICATION AND
SERVICING SCHEDULE
Item
Months
6 250 / 10 000
12 500 / 20 000
18 750 / 30 000
25 000 / 40 000
31 250 / 50 000
37 500 / 60 000
43 750 / 70 000
50 000 / 80 000
56 250 / 90 000
62 500 / 100 000
68 750 / 110 000
75 000 / 120 000
81 250 / 130 000
87 500 / 140 000
93 750 / 150 000
100 000 / 160 000
106 250 / 170 000
112 500 / 180 000
118 750 / 190 000
125 000 / 200 000
131 250 / 210 000
137 500 / 220 000
143 750 / 230 000
150 000 / 240 000
156250 / 250 000
162 500 / 260 000
168 750 / 270 000
175 000 / 280 000
181 250 / 290 000
187 500 / 300 000
193 750 / 310 000
200 000 / 320 000
250 000 / 400 000
300 000 / 480 000
LUBRICANT
&/OR
PART
2
07 TRANSMISSION
Allison Automatic transmission equipped with retarder,
change oil and filters (if filled with standard oil)
16 6
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Dexron-III
Allison transmission equipped with retarder, change oil (if
filled with TranSynd
TM
/ TES 295 Synthetic Fluid only)
3
16 48
•
TranSynd
TM
Synthetic Fluid
/ TES 295
Allison Automatic transmission without retarder, change oil
and filters (if filled with standard oil)
16 12
•
•
•
•
•
•
•
•
Dexron-III
Allison transmission without retarder, change oil (if filled
with TranSynd
TM
/ TES 295 Synthetic Fluid only)
3
16 48
•
TranSynd
TM
Synthetic Fluid
/ TES 295
Allison transmission with or without retarder, change filters
(if filled with TranSynd
TM
/ TES 295 Synthetic Fluid only)
16 12
•
•
Filters #572050
Transmission oil cooler, replace unit if vehicle is equipped
with transmission retarder
43 24
•
Castrol Syntrans grade SAE
75W-85
09 PROPELLER SHAFT
Grease one fitting on each universal joint and slip joint 34 6
• • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • •
Multipurpose grease
11 REAR AXLE
Differential, check oil level, add if necessary 35 6
• • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • •
Multigrade gear oil
Differential, change oil, clean breathers 35 12
•
•
Multigrade gear oil
Differential, change oil, clean breathers 35 48
•
Full synthetic gear oil
Tag axle lever pivot, grease one fitting on each pivot 15 6
• • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • •
Multi purpose grease
12 BRAKE & AIR
Air tanks, drain water from all tanks 7 12
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
-------
Accessories air filter, change filter element 3 24
•
•
Filter element #641340
Air dryer, change cartridge 36 24
•
•
Cartridge #3097369
Brake pads, check pad wear indicator and perform caliper
slide check
- 12
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Section 12 of Maintenance
Manual
1
Proceed to maintenance operation at distance indicated on odometer or specified number of months, whichever comes first.
2
See paragraph 2.5 & 2.6 of this section for lubricant and part number specifications.
3
When the transmission contains a mixture of fluids (defined as the quantity of non-TranSynd / TES 295 fluid remaining in the transmission after a
fluid change combined with the quantity of TranSynd
TM
required to fill the transmission to the proper level), perform the fluid and filter change
according to the non-TranSyndTM / non-TES 295 intervals.
To Next Page
Loading...
Need help?
General
