Yamaha F150A - Maintenance 10

Maintenance 10
Outline .............................................................................. 10-1
Maintenance interval chart 1 ................................................... 10-1
Maintenance interval chart 2 ................................................... 10-3
Predelivery check ............................................................ 10-4
Checking the battery ............................................................... 10-4
Checking the cooling water pilot hole ...................................... 10-5
Checking the engine oil level ................................................... 10-5
Checking the main switch/stop switch/choke switch ............... 10-5
Checking the fuel line .............................................................. 10-6
Checking the gear oil level ...................................................... 10-6
Checking the shift link/shift cable and throttle link/
throttle cable/throttle pick-up timing ......................................... 10-6
Checking the outboard motor mounting height ....................... 10-6
Checking the power trim and tilt unit ....................................... 10-7
Checking the steering system ................................................. 10-7
Checking the throttle cable and shift cable .............................. 10-7
Test run ................................................................................... 10-7
Break-in ................................................................................... 10-8
After test run ............................................................................ 10-8
General periodic maintenance ....................................... 10-8
Checking the anode ................................................................ 10-8
Checking the battery ............................................................... 10-8
Checking the cooling water inlet .............................................. 10-8
Checking the cooling water pilot hole ...................................... 10-9
Checking the engine idle speed/noise ..................................... 10-9
Changing the engine oil ........................................................... 10-9
Checking the engine oil level ................................................. 10-10
Replacing the oil filter ............................................................ 10-10
Checking the exhaust guide/exhaust manifold ...................... 10-11
Checking the main switch/stop switch/choke switch ............. 10-11
Checking the fuel filter ........................................................... 10-11
Checking the fuel pump ......................................................... 10-11
Checking for fuel leakage/oil leakage .................................... 10-11
Changing the gear oil ............................................................ 10-11
Checking the gear oil level .................................................... 10-12
Greasing points ..................................................................... 10-12
Checking the PCV ................................................................. 10-14
Checking the propeller/propeller nut/cotter pin ...................... 10-14
Checking the PTT fluid level .................................................. 10-14
Checking the power trim and tilt unit operation ..................... 10-14