ELECTRICAL SYSTEM
M6040, M7040, WSM
9-S5
ENGINE KEY SWITCH SHUT-OFF SYSTEM
4WD
GAUGES
Symptom Probable Cause Solution
Reference
Page
Engine Does Not
Stop When Main
Switch Is Turned OFF
Fuse blown Replace 9-S11
Key stop relay defective Replace 9-S43
Engine stop relay defective Replace 9-S43
Meter panel defective Replace 9-S25
Wiring harness disconnected or improperly
connected
Repair or replace –
Engine Does Not
Start
Fuse or slow blow fuse blown Replace 9-S11
Engine stop solenoid defective Replace 9-S18
Engine stop relay defective Replace 9-S43
Key stop relay defective Replace 9-S43
PTO switch defective Replace 9-S29
Shuttle neutral switch defective Replace 9-S30
Symptom Probable Cause Solution
Reference
Page
Front Wheel Does
Not Drive When 4WD
Switch is Turned ON
4WD switch or wiring harness is defective Replace 9-S33
4WD solenoid valve defective Replace 9-S47
Front Wheel Drive
Not Be Cancelled
4WD switch or wiring harness is defective Repair or replace 9-S33
4WD solenoid valve defective Replace 9-S47
Symptom Probable Cause Solution
Reference
Page
Fuel Gauge Does Not
Function
Fuel level sensor defective Replace 9-S32
Wiring harness disconnected or improperly
connected (between meter panel and fuel unit)
Repair or replace –
Circuit in meter panel defective Replace –
Coolant Temperature
Gauge Does Not
Function
Coolant temperature gauge defective Replace 9-S25
Coolant temperature sensor defective Replace 9-S28
Wiring harness disconnected or improperly
connected (between meter panel and coolant
temperature sensor)
Repair or replace –
Circuit in meter panel defective Replace 9-S25
To Next Page
Loading...
