Exchanged/Repaired/Assembled
Components/Groups
Tests and Calibrations to be Executed
(see Dialog+ Service Manual, Chapter 4 and 5)
Tests and Measures to
be Executed
5.1 Inspection Protocol for Automatic Blood Pressure Measurement ABPM
4.9.4.23 Setting Servomotor for Disinfection Valve VD
4.9.4.21 Gap SAKA and SAKV
4.9.4.20 Calibration Pressure Reducer Valve DMV
4.9.4.19 Calibration Dialyser Inlet Throttle Valve DDE
4.9.4.18 Calibration Outlet Flow Pump Nonreturn Valve RVFPA
4.9.4.17 Calibration Dialysate Nonreturn Valve RVDA
4.9.4.16 Calibration Inlet Flow Pump Nonreturn Valve RVFPE
4.9.4.13 Calibration Flow Rate of BPA and BPV/OSP
4.9.4.10 Calibration BICLF and ENDLF Ratio
4.9.4.9 Calibration Safety Air Detector SAD Version Version 3
4.9.4.8 Calibration of Flow Rate UFP, BICP and KP
4.9.4.7 Calibration Blood Leak Detector Type 2
4.9.4.6 Calibration Conductivity Sensors BICLF and ENDLF/ENDLF_S
4.9.4.5 Calibration Dialysis Temperature Sensors TSBIC and TSD/TSD_S/TSDE
4.9.4.4 Calibration Degassing TSE/TSHE
4.9.4.3 Calibration Pressure Sensors of Water Side PE and PDA
4.9.4.1 Calibration Pressure Sensors Blood Side PA, PV, PBE and PBS
4.9.2.26 1.26 Option Battery
4.9.2.25 Test 1.25 HDF Online Valves and Detectors
4.9.2.23 Test 1.23 BIC Cartridge Valves and Coupling Detectors
4.9.2.14 Test 1.14 Bypass and Disinfection Valves
4.9.2.13 Test 1.13 Balance Chamber Valves
4.9.2.8 Test 1.8 Coupling Detectors
4.9.2.7 Test 1.7 Air Sensor SAD, Red Sensor
4.9.2.5 Test 1.5 Tubing Clamps
4.9.2.1 Test 1.1 Staff Call, Alarms, Power Off
4.9.1.8 DBI Test (BSL) or DSI Test (Crit-Line) or DCI Test
4.9.1.3 Touch Screen Calibration
4.9.1.1 Buttons, Lamps and Sounds
3.8.2.8 Perform Disinfection after repair
3.8.2.7 Electrical Safety Check
3.8.2.6 Test Run
3.8.2.5 Test Run UF Comparison Measurement
3.8.2.4 Conductivity Test Run, Temperature Comparison Measurement
3.8.2.3 Self Test
3.8.2.2 Check System Configuration, Production Report and Set if Necessary
3.8.2.1 Install Software
1.
Automatic Blood Pressure Measurement: ABPM
◆ ◆ ◆
2.
Board, Analog: AB
◆◆◆◆◆◆ ◆ ◆◆◆◆◆
3.
Board, Basic: BB
◆ ◆ ◆ ◆
4.
Board, Digital: DB
◆◆◆◆ ◆ ◆◆◆◆◆
5.
Board, Front Panel: FPB
◆ ◆ ◆
6.
Board, HDF Online HOB
◆ ◆◆
7.
Board, Mother: TLC
◆ ◆ ◆ ◆
8.
Board, Optical Status Display: OSD
◆ ◆◆ ◆
9.
Board, Power Motors: PBM
◆ ◆ ◆
10.
Board, Power Valves: PBV
◆◆ ◆
11.
Compact Flash Card CFC
◆ ◆ ◆ ◆
12.
Coupling, Dialyser
◆ ◆
13.
Detector, Blood Leak: BL
◆ ◆ ◆ ◆ ◆
14.
Detector, Safety Air: SAD
◆◆◆◆ ◆
15.
Throttle: DBK
◆ ◆ ◆
16.
Throttle: DDE
◆ ◆ ◆◆
17.
Valve, Pressure Reducer: DMV
◆ ◆
18.
Chamber, Degassing: EK
◆◆ ◆
19.
Filter: FBK1; FBK2; FBIC; FVD; FB; FK
◆ ◆ ◆
20.
Filter, Hydrophobic: HFB
◆◆ ◆
21.
Heater
◆ ◆ ◆ ◆
22.
Clamp, Tubing: SAKV; SAKA
◆◆◆◆ ◆
23.
Rods, Concentrate Suction; o-ring
◆ ◆ ◆
24.
Manometer Connection; Protection Filter; Tubing
◆◆ ◆
25.
Membranes, MSBK1/2 (Balance Chamber)
◆ ◆ ◆
26.
Monitor (TFT Display)
◆◆◆ ◆
27.
Drive Unit, Gear Pump
◆ ◆ ◆ ◆
28.
Cable, Mains, with Mains Plug
◆◆
29.
SMPS-MC Components: Relay, Buzzer, Capacitor
◆ ◆ ◆ ◆ ◆
30.
SMPS-MC
◆ ◆◆◆ ◆
31.
Option ABPM
◆ ◆ ◆
32.
Option Adimea (Kt/V-UV)
◆◆ ◆
33.
Option Battery
◆ ◆ ◆ ◆
34.
Option Bedside-Link-Modul: BSL
◆ ◆◆ ◆ ◆
35.
Option BIC Cartridge Holder
◆ ◆ ◆ ◆
36.
Option DCI
◆ ◆◆ ◆
37.
Option DF-Filter
◆ ◆ ◆
38.
Option DSI (Crit-Line)
◆ ◆◆ ◆
39.
Option Card Reader
◆ ◆ ◆
40.
Option Staff Call
◆ ◆◆
41.
Level Regulation Module
◆ ◆ ◆ ◆
42.
Pump: BPA; BPV
◆ ◆
43.
Pump, Piston: BICP; KP
◆ ◆ ◆ ◆
44.
Pump, Piston: UFP
◆ ◆ ◆◆
45.
Pump, Heparin
◆ ◆ ◆
46.
Pump, Level Regulation: LRP (PPR)
◆◆ ◆
47.
Pump, Gear: EP; FPA; FPE
◆ ◆ ◆ ◆
48.
Nonreturn Valve: RVDA
◆ ◆ ◆◆
49.
Nonreturn Valve: RVFPA
◆ ◆ ◆ ◆
50.
Nonreturn Valve: RVFPE
◆ ◆◆ ◆
51.
Sensor, Pressure: PDA; PE
◆ ◆ ◆ ◆
52.
Sensor, Conductivity: BICLF; ENDLF
◆◆ ◆ ◆◆
53.
Sensor, Level, Upline Tank: NSVB
◆ ◆ ◆
54.
Sensor, Reed: BKUS
◆ ◆
55.
Sensor, Reed: PSAUS; PSABF, FEDFFS, FEDHDFS
◆ ◆ ◆ ◆
56.
Sensor, Reed SBS1, SBS2
◆ ◆◆
57.
Sensor, Temperature: TSBIC; TSD; TSD_S; TSDE
◆ ◆ ◆ ◆ ◆
58.
Sensor, Temperature: TSE; TSHE
◆ ◆ ◆◆
59.
Software, Installation/Update
◆ ◆ ◆ ◆ ◆ ◆ ◆
60.
Rinsing Bridge
◆ ◆◆ ◆
61.
Touch Screen
◆ ◆ ◆ ◆
62.
Valve: VEB; VVBE
◆◆ ◆
63.
Valve: VBE; VDFF; VSB; VSAE; VSAA
◆ ◆ ◆ ◆
64.
Valve: VBP; VDE; VDA; VZ; VLA
◆ ◆◆ ◆
65.
Valve: VD
◆ ◆ ◆ ◆
66.
Valve: VDEBK1; VEBK1; VEBK2; VDEBK2; VDABK1;
VABK1; VABK2; VDABK2
◆ ◆ ◆ ◆
67.
Valve: VVB; VBICP; VBKO; VBKS ,BKUS
◆ ◆ ◆ ◆
BA-TE-DE08C M.KAY
-
Dialog+ SW9xx_sm_Chapter 3_1-2010.doc/pdf <100329> yymmdd
B. Braun Avitum AG
3.8.1 Repair Matrix
3.8 Measures after Repair
3. Repair Instructions 1/2010 3 –103
Dialog
+
SW 9.xx
To Next Page
Loading...
