Crescent CS7010 - Sheet 7, Kubota Diesel Engine System

24 - Electrical System 127Service Manual – CS7010™
Sheet 7, Kubota Diesel Engine System
FORMS.DSN - D SIZE FORM 1/12/99
AS NOTED.
UNITS IN [ ] ARE ISO METRIC
DIM. IN [ ] ARE MM.
NOTES UNLESS OTHERWISE
SPECIFIED
1. ALL DIMENSIONS IN INCHES.
2. DO NOT SCALE D RAWING.
3. ALL DIMENSIONS APPLY AFTER
PLATING AND HEAT TREATING,
BUT BEFORE PAINTING.
4. REMOVE ALL BURRS AND SHARP
EDGES.
APPROVED
APPROVED
APPROVED
CHECKED
FIRST USED ON SHEETASSY.
SIZE
CODE RE V.DWG. NO.
TITL E
D
SCALE
DRAWN
PROJ ENG
B
ORCAD
A
1
B C D E F G
A B C D E F G
2
3
4
5
1
2
3
4
5
BROOKLYN PARK, MINNESOTA AND IT HAS BEEN ISSUED WITH THE UNDERSTANDING THAT I T W ILL NOT BE REPRO-
DWG. NO.
THIS DRAWING AND THE DESIGN REPRESENTED HEREON IS THE PROPERTY OF NILFISK, INC.,
DUCED NOR COPIED NOR USED FOR ANY PURPOSE OTHER THAN FOR WHICH IT WAS ISSUED AND RECIPIENT
REV
SHEET
APPDECO D ATE
B
CONFIDENTIAL
DFTM
AGREES TO R ETURN IT UPON REQUEST.
REVISIONS7 OF 11
LADDER DIAGRAM
7 OF 11
56511580
56511580
BROOKLYN PARK, MINNESOTA 55445
NILFISK
CS7010
SEE SHEET 1
E1
E2
E3
GLOW PLUGS
C
NC
NO
KUBOTA DIESEL ENGINE SYSTEM
(MM) TO 1E2
CLOSES AT 235 F
CLOSES ABOVE 10 PSI
5-18-17
5-18-17
JSB
SMJ
WHT
BLU
BLK
RED/WHT
ORN/BLK
GRN
WHT/BLK
BRN
RED
PINK
RED
RED
YEL
ORN
BLK
GRY
RED
GRA/ORN
GRN/YEL
GRA/YEL
BLK
GRA
GRA/BRN
PINK/YEL BLK
GRA/BLU
VIO
RED
BLOCK GND
BAT 2 (+)
(Y) TO 1E4 IGNITION ON
(X) TO 1E3 START
(P) TO 1E2 RUN SIGNAL
(W) TO 1E3 THROTTLE OUTPUT 2
(T) TO 1E3 THROTTLE OUTPUT 1
(Q) 1E3 TO COOLANT TEMP INPUT
(Z) TO 1E4 GLOW PLUG
SERVICE TOOL
SERVICE TOOL
(HH) TO 1 F4
(KK) TO 1E2 STARTER
(LL) TO 1F2 BOND GND
M
M20
PUMP, DIESEL-PETRO
-+
D3
DIODE
ENGINE TEMP SW
J7-11
J7-5
D2
DIODE
J7-2
J7-3
X113-11
X113-5
X140-10
X113-4
X113-2
X113-9
J7-10
J7-4
X113-3
X113-1
X113-8
J7-1
G2
12v ALTERNATOR
B
S
I
G
OIL PRESSURE SWITCH
A
-
+
M15
FUEL ACTUATOR
12
J7-8
J7-9
B4
SENSOR ENGINE SPEED
1 2
F32
40 A FUSE
1 2
RELAY, GLOW PLUG
A
D
C
B
APECS 3000 GOVERNOR
B(+)
SPEED SELECT 2
SPEED SELECT 1
MAGNETIC PICKUP (+)
B(-)
ACTUATOR (+)
ACTUATOR (-)
MAGNETIC PICKUP (-)
SERVICE TOOL (Tx)
SERVICE TOOL (Rx)
M
DV6
STARTER
B(+)
B(-)
IGNITION
K13
1 2