23Service Manual – CS7010™ 03 - General Information
Maintenance Item
Interval
Day Wk Mo 15-20
Hrs
150
Hrs
400
Hrs
1000
Hrs
1500
Hrs
2000
Hrs
Lubricate squeegee caster wheels and pivot
X
Lubricate steering gears
X
Lubricate squeegee side wheels
X
Lubricate engine/battery bay latch
X
Lubricate recovery tank latch
X
Lubricate brake linkage
X
Check the electrolyte level in the battery (battery models)
X
Check the battery cables and connections
X
Rotate main broom
X
Inspect and clean solution lter
X
Rotate the scrub brushes
X
Inspect/adjust main and side brooms
X
Clean the DustGuard system spray nozzles
X
Inspect broom housing skirts
X
Check / Clean Hopper Dust Control Filter
X
Inspect hopper seals
X
Purge Detergent System (EcoFlex only)
X
Clean radiator
X
Perform general engine maintenance
X
Change engine oil and lter
X
Inspect and drain any oil buildup from the LP fuel EPR
X
Inspect complete air intake system (engine models only)
X
Check engine battery electrolyte level & terminals
X
Replace fuel lter (engine models only)
X
Change the spark plugs (LP and petrol only)
X
Flush the radiator
X
Replace Alternator Drive Belt
X
Check vacuum motor carbon brushes (1200 hrs)
X
Check main broom motor carbon brushes
X
Check side broom motor carbon brushes
X
Replace vacuum motor
X
Check scrub brush motor carbon brushes
X
Perform engine maintenance
X
Note: Refer to the engine manual listed in the Engine Manufacturers’ Technical Manuals list on
page 12 for additional engine maintenance information
To Next Page
Loading...
