PREVOST X3-45 COMMUTER User Manual

SECTION 01 : ENGINE
DOB 1300-1556 | X3-45 Commuter PA-1648 Maintenance Manual Section 01 revised Jan 2021
15
MAINTENANCE
Engine oil and filters change
Change engine oil and filters at the intervals
specified by the Lubrication And Servicing
Schedule in Section 24A: LUBRICATION &
SERVICING SCHEDULE.
NOTE
Oil filters must always
be changed when
changing the oil.
2.5.9 Oil Filters
There are two Extra Long Life full-flow oil filters
on theD13 OBD20 engine.
CAUTION
Volvo branded oil filters are designed to provide
the proper level of filtration and protection for Volvo
engines. Filter
s that do not meet the same
stringent requirements may void engine warranty.
FIGURE 8: D13 OBD20 OIL FILTERS
2.5.10 Oil Filters Change
WARNING
Hot oil can cause severe burns. DO NOT
allow hot oil to contact the skin. When
changing oil, wear protective gloves.
CAUTION
Volvo-
branded oil filters are designed to
provide the proper level of filtration and
protection for Volvo engine
s. Filters that do
not meet the same stringent requirements
may cause unsatisfactory results.
• Clean around the oil filter housing and
remove the filters using the oil filter wrench
or the oil filter socket.
• Prefill the new oil filters with approved
engine oil. Refer to Figure 9. Also,
lubricate the filter gaskets with engine oil
(1). Hand tightens the oil filters until they
contact the sealing surface of the oil filter
housing (2). Manually tighten the oil filters
an additional ¾ to 1 full turn (3).
FIGURE 9: OIL FILTER REPLACEMENT

PREVOST X3-45 COMMUTER Specifications

General

Engine	Volvo D13
Transmission	Allison B500
Fuel Type	Diesel
Length	45 ft (13.7 m)
Width	102 in (2.6 m)
Horsepower	500 hp
GVWR	54, 000 lbs
Height	141 in