FOREWORD
This handbook describes the diagnostic
procedures, maintenance adjustments,
disassembling and assembling of major
components and general repairs.
Apply to:
MODEL SANTANA on and after the following
body number:
VSFPSW10V00100001~
VSFPSW20V00100009~
Descriptions are classified into sections, each one
with an assigned number as found in the INDEX in
this page and the first page of each section contains
an index to such section.
This handbook must be kept in an adequate place
to be consulted when required.
The strict fulfilment of the specified tasks will allow
obtaining the best performance of the vehicle.
Replacement of parts when repairing should be
done with parts, tools and materials (lubricating
agents, sealers, etc.) from SANTANA, according
to the specifications described in each procedure.
All the information, illustrating materials and
specification in this handbook are based on latest
information of the product before publishing.
SANTANA reserves the rights to make changes
whenever it estimates convenient without previous
warning.
ALL RIGHTS RESERVED BY SANTANA MOTOR.
INDEX
MAINTENANCE AND LUBRICATION
HEATER AND VENTILATION
BUMPERS, FRONT HOOD AND
FRONTAL
STEERING, SUSPENSION,
WHEELS AND TIRES
General diagnosis
Front end alignment
Steering gear box and linkage
Steering wheel, column and lower shaft
Front suspension
Rear suspension
Wheels and tires
FRONT AND REAR
PROPELLER SHAFTS
Front drive shaft
Rear drive shaft
Front and rear propeller shafts
BRAKES
ENGINE
Engine general information
Engine repair
Cooling system
Fuel system and emissions control
system
Exhaust system
Lubrication system
TRANSMISSION
Manual transmission
Clutch
Transfer
Front and rear differential system
BODY ELECTRICAL SYSTEM
BODY SERVICE
TECHNICAL DATA
ELECTRICAL DIAGRAMS
SECTION
0B
1A
2
3
3-2
3A
3B
3C
3D
3E
3F
4
4A
4B
4C
5
6
6-2
6A
6B
6C
6K
6L
7
7A
7C
7D
7E
8
9
10
SANTANA MOTOR, S. A.
TECHNICAL DEPARTMENT
0B
1A
2
3
3A
3D
3B
3E
3F
4A
4B
4C
5
6A
6B
6K
6L
6C
7A
7C
7D
7E
8
9
3-2
4
6-2
3C
6
7
10
To Next Page
Loading...
Need help?
General