MAINTENANCE AND LUBRICATION 0B-3
MAINTENANCE UNDER SEVERE DRIVING CONDITIONS
If the vehicle is driven under the conditions stated under SEVERE DRIVING described below, it is advised to carry out the
MAINTENANCE operations on the corresponding parts, according to the particular intervals indicated in the following
table.
SEVERE DRIVING Codes:
A - Short and frequent trips.
B - Driving through muddy paths and/or grounds.
C - Driving through paths and/or dusty grounds.
D - Driving on very cold weather and/or salty paths.
E - Short and frequent trips under cold weather.
G - Town driving/ towing/ high speed driving/ Temperatures above 40° C/ Lubricants and fuel of low quality.
H - Towing.
I - Hired Vehicles.
-BCD---I
SEVERE
DRIVING
CODE
MAINTENANCE
MAINTENANCE
OPERATION
MAINTENANCE INTERVAL
KM
MILES
MONTHS
ITEM 1-1.
Accesory belt
I
R
15.000 9.000
12
60.000 36.000
48
A-CDE-G-I
ITEM 1-2.
Timing belt
R 60.000
36.000
48
A-CDE-G-I
ITEM 1-3.
Oil motor and filter
R
15.000 9.000
12
-BC-----I
ITEM 1-6. / 1-7.
Water radiator and air radiator
(intercooler)
I
10.000 6.000
8
--C----I
ITEM 1-8.
Air filter *1
I
R
2.500 1.500
2
30.000 18.000
24
-B------I
ITEM 1-9.
Exhaust system
I
15.000 9.000
12
--C---G-I
ITEM 2-1.
Fuel filter
R
10.000 6.000
8
--C---G-I
ITEM 2-2.
Water purge and residues from
the fuel filter
I
2.500 1.500
2
NOTE:
• «R» REPLACE OR CHANGE
• «I» INSPECT, CORRECT, LUBRICATE, CLEAN, PURGE OR TIGHTEN as necessary
• «*1» INSPECT OR REPLACE MORE OFTEN IF NECESSARY
-B--E--HI
ITEM 3-1./3-2./3-3./4-5.
Gear box oil, transfer box,
differential groups
and rotating pivots
R
30.000 18.000
24
-B-DE--HI
ITEM 3-4.
Propeller shafts
I
15.000 9.000
12
-BCD---HI
ITEM 4-4.
Mechanical steering system
and axle housing
I
15.000 9.000
12
-BC----HI
ITEM 4-8.
Dampers, silent-blocks
and springs
I
15.000 9.000
12
--C---G-I
ITEM 2-5.
Fuel prefilter
R
10.000 6.000
8
To Next Page
Loading...
Need help?
General