Daewoo MATIZ - Section 4 A Hydraulic Brakes

DAEWOO M-150 BL2
SECTION 4A
HYDRAULIC BRAKES
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 4A-2. . . . . . . . . . . . . . . . . .
Warning Lamp Operation 4A-2. . . . . . . . . . . . . . . . . . .
Component Locator 4A-3. . . . . . . . . . . . . . . . . . . . . . . .
Brake System (Non-ABS) 4A-3. . . . . . . . . . . . . . . . . .
Diagnostic Information and Procedures 4A-4. . . . .
Brake System Testing 4A-4. . . . . . . . . . . . . . . . . . . . . .
Brake Hose Inspection 4A-4. . . . . . . . . . . . . . . . . . . . .
Warning Lamp Operation 4A-5. . . . . . . . . . . . . . . . . . .
Brake System Fault 4A-5. . . . . . . . . . . . . . . . . . . . . . . .
Manual Bleeding the Brakes 4A-6. . . . . . . . . . . . . . . .
Pedal Travel Check 4A-6. . . . . . . . . . . . . . . . . . . . . . . .
Brake Pedal Free Play Inspection 4A-7. . . . . . . . . . .
Repair Instructions 4A-8. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 4A-8. . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Hose (Front) 4A-8. . . . . . . . . . . . . . . . . . . . . . . .
Brake Hose (Rear) 4A-9. . . . . . . . . . . . . . . . . . . . . . . .
Stoplamp Switch 4A-9. . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Pedal 4A-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications 4A-13. . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications 4A-13. . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 4A-13. . . . . . . . . .
Schematic and Routing Diagrams 4A-14. . . . . . . . . .
Brake Lamp Warning Circuit 4A-14. . . . . . . . . . . . . . .
Stoplamp Switch Circuit 4A-14. . . . . . . . . . . . . . . . . . .