Daewoo MATIZ - Section 4 F Antilock Brake System

DAEWOO M-150 BL2
SECTION 4F
ANTILOCK BRAKE SYSTEM
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
CAUTION: Don’t diagnosis the Antilock Brake System (ABS) under the vehicle moving status. Because the
ABS function will be stopped.
TABLE OF CONTENTS
Description and Operation 4F-3. . . . . . . . . . . . . . . . . .
ABS System Components 4F-3. . . . . . . . . . . . . . . . . .
Hydraulic Unit 4F-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
EBCM (Electronic Brake Control Module) 4F-4. . . . .
Wheel Speed Sensors and Rings 4F-5. . . . . . . . . . . .
Electronic Brake Distribution 4F-5. . . . . . . . . . . . . . . .
Indicator 4F-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
EBCM Connector 4F-6. . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Fluid Flow Diagrams 4F-7. . . . . . . . . . . . . .
Normal Braking Mode 4F-7. . . . . . . . . . . . . . . . . . . .
Isolation Mode (Pressure Maintain) 4F-8. . . . . . . .
Dump Mode (Pressure Decrease) 4F-9. . . . . . . . .
Reapply Mode (Pressure Increase) 4F-10. . . . . . .
Proportioning Function 4F-11. . . . . . . . . . . . . . . . . .
Visual Identification 4F-12. . . . . . . . . . . . . . . . . . . . . . .
EBCM Connector Face View 4F-12. . . . . . . . . . . . . . .
Component Locator 4F-13. . . . . . . . . . . . . . . . . . . . . . .
ABS 4F-13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Information and Procedures 4F-16. . . .
DTC 0354 Left Front Wheel Speed Sensor
Circuit Open or Shorted 4F-16. . . . . . . . . . . . . . . . .
DTC 0355 Left Front Wheel Speed Sensor
Poor Air Gap or Missing Tooth Ring 4F-20. . . . . . .
DTC 0356 Left Front Wheel Speed Sensor
Circuit Intermittent Shorted 4F-22. . . . . . . . . . . . . .
DTC 0404 Right Front Wheel Speed Sensor
Circuit Open or Shorted 4F-24. . . . . . . . . . . . . . . . .
DTC 0405 Right Front Wheel Speed Sensor
Poor Air Gap or Missing Tooth Ring 4F-28. . . . . . .
DTC 0406 Right Front Wheel Speed Sensor
Circuit Intermittent Shorted 4F-30. . . . . . . . . . . . . .
DTC 0454 Left Rear Wheel Speed Sensor
Circuit Open or Shorted 4F-32. . . . . . . . . . . . . . . . .
DTC 0455 Left Rear Wheel Speed Sensor
Poor Air Gap or Missing Tooth Ring 4F-36. . . . . . .
DTC 0456 Left Rear Wheel Speed Sensor
Circuit Intermittent Shorted 4F-38. . . . . . . . . . . . . .
DTC 0504 Right Rear Wheel Speed Sensor
Circuit Open or Shorted 4F-42. . . . . . . . . . . . . . . . .
DTC 0505 Right Rear Wheel Speed Sensor
Poor Air Gap or Missing Tooth Ring 4F-46. . . . . . .
DTC 0506 Right Rear Wheel Speed Sensor
Circuit Intermittent Shorted 4F-48. . . . . . . . . . . . . .
DTC 0601 Left Front Dump Shorted or
Driver Open 4F-52. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0602 Left Front Dump Open or
Driver Shorted 4F-54. . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0651 Left Front Isolation Shorted or
Driver Open 4F-56. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0652 Left Front Isolation Open or
Driver Shorted 4F-58. . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0701 Right Front Dump Shorted or
Driver Open 4F-60. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0702 Right Front Dump Open or
Driver Shorted 4F-62. . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0751 Right Front Isolation Shorted or
Driver Open 4F-64. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0752 Right Front Isolation Open or
Driver Shorted 4F-66. . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0801 Left Rear Dump Shorted or
Driver Open 4F-68. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0802 Left Rear Dump Open or
Driver Shorted 4F-70. . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0851 Left Rear Isolation Shorted or
Driver Open 4F-72. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0852 Left Rear Isolation Open or
Driver Shorted 4F-74. . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0901 Right Rear Dump Shorted or
Driver Open 4F-76. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC 0902 Right Rear Dump Open or
Driver Shorted 4F-78. . . . . . . . . . . . . . . . . . . . . . . . .