Daewoo MATIZ - Page 704

DAEWOO M-150 BL2
SECTION 6C
POWER STEERING GEAR
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 6C-2. . . . . . . . . . . . . . . . . .
Power Rack and Pinion 6C-2. . . . . . . . . . . . . . . . . . . .
Diagnostic Information and Procedures 6C-3. . . . .
Power Rack and Pinion Steering Gear 6C-3. . . . . . .
Adjust the Free Load of the Steering Gear 6C-5. . .
Repair Instructions 6C-6. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 6C-6. . . . . . . . . . . . . . . . . . . . . . . . . .
Rack and Pinion Assembly 6C-6. . . . . . . . . . . . . . . . .
Power Steering Gear Rack and Pinion Boot 6C-7. . .
Unit Repair 6C-8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tie Rod End Boot 6C-8. . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Cylinder Lines 6C-8. . . . . . . . . . . . . . . . . . . .
Rack and Pinion Steering Gear 6C-9. . . . . . . . . . . . . .
Assembly
Specifications 6C-13. . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications 6C-13. . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 6C-13. . . . . . . . . .