Daewoo MATIZ - Page 717

DAEWOO M-150 BL2
SECTION 6D
MANUAL STEERING GEAR
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 6D-2. . . . . . . . . . . . . . . . . .
Manual Rack and Pinion 6D-2. . . . . . . . . . . . . . . . . . . .
Component Locator 6D-3. . . . . . . . . . . . . . . . . . . . . . . .
Manual Rack and Pinion Steering Gear 6D-3. . . . . . .
Diagnostic Information and Procedures 6D-4. . . . .
Manual Rack and Pinion Steering Gear 6D-4. . . . . . .
Straight-Ahead Check 6D-5. . . . . . . . . . . . . . . . . . . . . .
Steering Wheel Restoration 6D-6. . . . . . . . . . . . . . . . .
Check The Turning Resistance of the
Tie Rod End or Tie Rod 6D-6. . . . . . . . . . . . . . . . . . . .
Adjust the Free Load of the Steering Gear 6D-6. . . .
Repair Instructions 6D-7. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 6D-7. . . . . . . . . . . . . . . . . . . . . . . . . .
Tie Rod End 6D-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rack and Pinion Boot 6D-8. . . . . . . . . . . . . . . . . . . . . .
Rack and Pinion Steering Gear Assembly 6D-9. . . .
Unit Repair 6D-11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tie Rod End Boot 6D-11. . . . . . . . . . . . . . . . . . . . . . . .
Rack and Pinion 6D-11. . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications 6D-17. . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications 6D-17. . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 6D-17. . . . . . . . . .
Special Tools and Equipment 6D-18. . . . . . . . . . . . . .
Special Tools Table 6D-18. . . . . . . . . . . . . . . . . . . . . . .