Home
Renault
Automobile
Duster 2007
Page 343
Renault Duster 2007 - Page 343
1162 pages
Manual
Save Page as PDF
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
19A
-
42
COOLING
Coolant temperature sensor: Removal - Refitting
K9K
19A
a
Perform the following operations:
-
top up the cooling system,
-
bleed the cooling system (see
19A
,
Cooling
,
Cool-
ing system: Draining - Refilling
, page
19A-6
) .
342
344
Table of Contents
Main Page
Duster - Chapitre 1
23
Table of Contents
23
Crankshaft Seal on Timing End: Removal - Refitting
27
Crankshaft Seal, Gearbox End: Removal - Refitting
31
Lower Cover: Removal - Refitting
35
Conrod Bearing Shell: Removal - Refitting
50
Engine Oil: Draining - Refilling
58
Oil Filter: Removal - Refitting
60
Oil-Coolant Heat Exchanger: Removal - Refitting
63
Oil Pressure Sensor: Removal - Refitting
68
Oil Pump: Removal - Refitting
70
Oil Pressure: Check
72
Multifunction Support: Removal - Refitting
74
Engine - Gearbox Assembly: Removal - Refitting
80
Flywheel: Removal - Refitting
101
Top and Front of Engine
104
Pressure at End of Compression: Check
104
Accessories Belt: Removal - Refitting
105
Crankshaft Accessories Pulley: Removal - Refitting
113
Timing Belt: Removal - Refitting
120
Rocker Cover: Removal - Refitting
145
Camshaft: Removal - Refitting
152
Camshaft Seal, Timing End: Removal - Refitting
159
Oil Decanter: Removal - Refitting
171
Fuel Mixture
174
Air Inlet: Description
174
Air Resonator: Removal - Refitting
175
Air Filter: Removal - Refitting
176
Air Filter Unit: Removal - Refitting
179
Fuel Mixture
179
Throttle Valve: Removal - Refitting
184
Inlet Distributor: Removal - Refitting
185
Injector Holder Shim: Removal - Refitting
187
Exhaust Manifold: Removal - Refitting
189
Turbocharging
195
Turbocharger: Removal - Refitting
195
Turbocharger Oil Pipe: Removal - Refitting
198
Intercooler: Removal - Refitting
202
Fuel Circuit: Operating Diagram
204
Fuel Supply
204
Manual Priming Pump: Removal - Refitting
206
Diesel Filter: Removal - Refitting
208
Fuel Pressure: Check
212
Fuel Flow: Check
214
Diesel Injection
217
Diesel Injection: List and Location of Components
217
Diesel Injection Computer: Removal - Refitting
221
Camshaft Position Sensor: Removal - Refitting
223
Diesel Injection
223
Crankshaft Position Sensor: Removal - Refitting
224
High Pressure Pump: Removal - Refitting
225
Flow Actuator: Removal - Refitting
230
Venturi: Removal - Refitting
232
High Pressure Pipe: Check
234
High Pressure Pipe between Pump and Rail: Removal - Refitting
235
High Pressure Pipe between Rail and Injector: Removal - Refitting
238
Injector Rail: Removal - Refitting
241
Fuel Temperature Sensor: Removal - Refitting
244
Injector Leak Flow: Check
246
Diesel Injector: Removal - Refitting
248
Accelerometer: Removal - Refitting
253
Pre-Postheating Unit: Removal - Refitting
255
Heater Plugs: Removal - Refitting
256
Exhaust Gas Recirculation: List and Location of Components
258
Antipollution
258
Fuel Vapour Absorber: Removal - Refitting
259
Antipollution
261
Exhaust Gas Recirculation Solenoid Valve: Removal - Refitting
261
Exhaust Gas Cooler: Removal - Refitting
264
Exhaust Gas Recirculation Assembly: Removal - Refitting
266
Exhaust Gas Recirculation Rigid Pipe: Removal - Refitting
269
Starting - Charging
271
Alternator: Removal - Refitting
271
Starter: Removal - Refitting
278
Alternator Pulley: Removal - Refitting
282
Ignition
289
Coils: Removal - Refitting
289
Petrol Injection
291
Petrol Injection: List and Location of Components
291
Oxygen Sensors: Removal - Refitting
294
Throttle Valve Potentiometer: Removal -Refitting
296
Petrol Injection Computer: Removal - Refitting
297
Crankshaft Position Sensor: Removal - Refitting
299
Injector Rail - Injectors: Removal - Refitting
300
Engine Cooling System: Operating Diagram
302
Engine Cooling System: Specifications
303
Engine Cooling System: Check
304
Engine Cooling Circuit: List and Location of Components
306
Cooling System: Draining - Refilling
307
Cooling Radiator: Removal - Refitting
310
Coolant Pump: Removal - Refitting
314
Thermostat: Removal - Refitting
320
Water Chamber: Removal - Refitting
323
Engine Cooling Fan Assembly: Removal - Refitting
328
Coolant Pump Inlet Pipe: Removal - Refitting
335
Expansion Bottle: Removal - Refitting
339
Coolant Temperature Sensor: Removal - Refitting
341
Exhaust
346
Exhaust: List and Location of Components
346
Exhaust: Precautions for the Repair
351
Catalytic Converter: Removal - Refitting
355
Expansion Chamber: Removal - Refitting
362
Intermediate Pipe: Removal - Refitting
363
Exhaust
363
19B
363
Silencer: Removal - Refitting
365
19C
366
Tank
366
Fuel Tank: Draining
366
Fuel Tank: Removal - Refitting
368
Fuel Level Sensor Module: Removal - Refitting
373
19D
376
Engine Mounting
376
Suspended Engine Mounting: Tightening Torque
376
Left-Hand Suspended Engine Mounting: Removal - Refitting
377
Right-Hand Suspended Engine Mounting: Removal - Refitting
379
Lower Engine Tie-Bar: Removal - Refitting
383
Duster - Chapitre 2
385
Clutch
386
Clutch: Precautions for the Repair
386
Clutch: Specifications
387
Pressure Plate - Disc: Removal - Refitting
389
Clutch Thrust Bearing: Removal - Refitting
391
Manual Gearbox
392
Manual Gearbox Oils: Draining - Filling
392
Differential Output Seal: Removal - Refitting
393
Manual Gearbox: Removal - Refitting
395
5Th Gear Housing: Removal - Refitting
409
5Th Gear Sprockets and Synchronisers: Removal - Refitting
412
Input Shaft Lip Seal: Removal - Refitting
416
Reverse Gear Switch: Removal - Refitting
417
Driveshafts
418
Front Left-Hand Driveshaft: Removal - Refitting
418
Front Right-Hand Driveshaft: Removal - Refitting
421
Relay Shaft Bearing: Removal - Refitting 29A-6
423
Front Driveshaft Gaiter, Wheel Side: Removal - Refitting
424
Front Right-Hand Driveshaft Gaiter, Gearbox Side: Removal - Refitting
428
Front Left-Hand Driveshaft Gaiter, Gearbox Side: Removal - Refitting
433
Duster - Chapitre 3
439
Brake Circuit: Operating Diagram
442
General Information
442
Brake Circuit: Precautions for the Repair
443
Braking Circuit: Bleed
445
Brake Circuit: Tightening Torque
447
Rigid Brake Pipe: Repair
448
Brake Fluid: Specifications
453
Brake: Specifications
454
Steering: Tightening Torque
455
Axle Assemblies: Check
456
Front Axle System: Tightening Torque
457
Front Axle System: Adjustment
459
Rear Axle System: Tightening Torque
460
Front Axle Components
461
Front Axle Components: Precautions for the Repair
461
Front Brake Pads: Removal - Refitting
463
Front Axle Components
465
Front Brake Hose: Removal - Refitting
465
Front Brake Calliper: Removal - Refitting
467
Front Brake Calliper: Repair
469
Front Brake Calliper Mounting: Removal - Refitting
471
Front Brake Disc Protector: Removal - Refitting
473
Front Brake Disc: Removal - Refitting
475
Front Brake Disc: Description
478
Hydraulic Unit - Master Cylinder Brake Pipe: Removal - Refitting
479
Hydraulic Unit - Underbody Union Brake Pipe: Removal - Refitting
481
Hydraulic Unit - Front Left-Hand Calliper Brake Pipe: Removal - Refitting
483
Hydraulic Unit - Front Right-Hand Calliper Brake Pipe: Removal - Refitting
485
Front Driveshaft Hub Carrier: Removal - Refitting
487
Front Hub Carrier Bearing: Removal - Refitting
490
Front Shock Absorber and Spring: Removal - Refitting
493
Front Axle Components
499
Front Driveshaft Lower Arm: Removal - Refitting
499
Front Driveshaft Lower Arm Ball Joint: Check
501
Front Axle Subframe: Removal - Refitting
502
Front Anti-Roll Bar: Removal - Refitting
506
Rear Axle Components
507
Rear Axle Components: Precautions for the Repair
507
Rear Brake Lining: Removal - Refitting
508
Rear Brake Cylinder: Removal - Refitting
511
Rear Brake Drum: Removal - Refitting
513
Rear Brake Drum: Description
515
Rigid Brake Pipe: Removal - Refitting
516
Shock Absorber: Removal - Refitting
518
Rear Suspension Spring: Removal - Refitting
520
Rear Axle Rubber Bearing: Removal - Refitting
522
Complete Rear Axle System: Removal - Refitting
525
Wheel: Removal - Refitting
528
Wheels and Tyres
528
Wheel: Balancing
531
Wheels and Tyres
531
Tyre: Precautions for the Repair
534
Tyres: Identification
535
Tyres: Removal - Refitting
536
Tyre: Repair
538
Wheel Rim: Identification
541
Emergency Spare Wheel Carrier: Removal - Refitting
542
Steering Assembly
544
Steering: List and Location of Components
544
Steering: Precautions for the Repair
545
Track Rod: Removal - Refitting
547
Axial Ball Joint Linkage: Removal - Refitting
548
Steering Column: Removal - Refitting
550
Steering Box Gaiter: Removal - Refitting
552
Bulkhead Seal: Removal - Refitting
553
Steering Column Adjustment Handle: Removal - Refitting
554
Steering Wheel: Removal - Refitting
556
Power Assisted Steering
558
Power-Assisted Steering Pump Pressure: Check
558
Power Assisted Steering
562
Power-Assisted Steering Pump: Removal - Refitting
562
Power-Assisted Steering
563
Power-Assisted Steering Pump Assembly: Removal - Refitting
570
Power-Assisted Steering Pipes: Removal - Refitting
572
Brake Mechanism: Precautions for the Repair
584
Mechanical Component Controls
584
Master Cylinder: Removal - Refitting
585
Master Cylinder - Front Right-Hand Calliper Brake Pipe: Removal - Refitting
588
Master Cylinder - Front Left-Hand Calliper Brake Pipe: Removal - Refitting
590
Brake Servo Non-Return Valve: Removal - Refitting
592
Brake Servo: Removal - Refitting
594
Vacuum Pump: Removal - Refitting
597
Pedal Yoke: Removal - Refitting
599
Accelerator Pedal: Removal - Refitting
603
Accelerator Pedal Cable: Removal - Refitting
607
Brake Pedal: Removal - Refitting
609
Brake Pedal Switch: Removal - Refitting
610
Parking Brake Lever: Removal - Refitting
612
Mechanical Component Controls
613
Parking Brake Lever: Adjustment
613
Clutch Control: List and Location of Components
614
Clutch Pedal: Removal - Refitting
616
Clutch Pedal Switch: Removal - Refitting
618
Clutch Circuit: Bleed
620
Clutch Master Cylinder: Removal - Refitting
627
Clutch Circuit: Removal - Refitting
630
Gear Control Unit: Removal - Refitting
633
Parking Brake Cables: Removal - Refitting
636
Brake Servo: Check
638
ABS: List and Location of Components
639
Anti-Lock Braking System
639
ABS: Precautions for the Repair
642
Hydraulic Brake Unit: Removal - Refitting
643
Front Wheel Speed Sensor: Removal - Refitting
645
Rear Wheel Speed Sensor: Removal - Refitting
647
Duster - Section 5
650
Front Side Door Window Winder Handle: Removal - Refitting
652
Side Opening Element Mechanisms
652
Rear Side Door Window Winder Handle: Removal - Refitting
653
Front Side Door Check Strap: Removal - Refitting
654
Front Side Door Striker Panel: Removal - Refitting
655
Front Side Door Lock: Removal - Refitting
656
Front Side Door Lock Barrel: Removal - Refitting
658
Exterior Door Handle: Removal - Refitting
659
Front Side Door Interior Opening Control: Removal - Refitting
660
Front Side Door Electric Window Mechanism: Removal - Refitting
661
Front Side Door Manual Window Winder Mechanism: Removal - Refitting
663
Rear Side Door Striker Panel: Removal - Refitting
665
Rear Side Door Lock: Removal - Refitting
666
Side Opening Element Mechanisms
666
Rear Side Door Interior Opening Control: Removal - Refitting
668
Rear Side Door Manual Window Winder Mechanism: Removal - Refitting
669
Rear Side Door Slide Mounting: Removal - Refitting
671
Front Side Door Slide Mounting: Removal - Refitting
672
Rear Side Door Check Strap: Removal - Refitting
674
Exterior Rear Opening Element Assembly: Exploded View
675
Non-Side Opening Element Mechanisms
675
Non-Side Opening Element Mechanisms
676
Tailgate Strut: Removal - Refitting
683
Tailgate Exterior Opening Control: Removal - Refitting
684
Windscreen: Removal - Refitting
685
Front Side Door Sliding Window: Removal - Refitting
687
Rear Side Door Sliding Window: Removal - Refitting
689
Rear Quarter Panel Window: Removal - Refitting
691
Rear Screen: Removal - Refitting
692
Exterior Protection
693
Front Bumper Assembly: Exploded View
693
Rear Bumper Assembly: Exploded View
695
Exterior Body Front Trim Assembly: Exploded View
697
Front Bumper: Removal - Refitting
698
Rear Bumper: Removal - Refitting
701
Front Wheel Arch Liner: Removal - Refitting
702
Rear Wheel Arch Liner: Removal - Refitting
703
Exterior Body Side Trim Assembly: Exploded View
704
Exterior Equipment
704
Door Mirror: Removal - Refitting
705
Door Mirror Glass: Removal - Refitting
706
Rear Badges: Removal - Refitting
707
Dashboard: Removal - Refitting
708
Interior Equipment
708
Dashboard: Stripping - Rebuilding
713
Dashboard Air Vent: Removal - Refitting
714
Glovebox Cover: Removal - Refitting
716
Centre Console: Removal - Refitting
717
Interior Rear-View Mirror: Removal - Refitting
719
Sun Visor: Removal - Refitting
720
Grab Handle: Removal - Refitting
721
Duster - Chapitre 6
723
Heating
724
Heating: List and Location of Components
724
Cabin Filter: Removal - Refitting
731
Front Air Distribution Duct: Removal - Refitting
732
Rear Air Distribution Duct: Removal - Refitting
733
Recirculation Control Cable: Removal - Refitting
734
Air Distribution Cable: Removal - Refitting
736
Air Mixing Cable: Removal - Refitting
738
Distribution Unit: Removal - Refitting
740
Heater Matrix: Removal - Refitting
744
Fan Assembly: Removal - Refitting
747
Heating Resistor Relays: Removal - Refitting
748
Heating Resistors: Removal - Refitting
749
Passenger Compartment Fan Assembly Control Unit: Removal - Refitting
751
Control Panel: Removal - Refitting
752
Air Conditioning
753
Air Conditioning: List and Location of Components
753
Air Conditioning: Parts and Consumables for the Repair
761
Condenser: Removal - Refitting
762
Compressor: Removal - Refitting
764
Expansion Valve: Removal - Refitting
768
Refrigerant Pipe Seal: Removal - Refitting
770
Refrigerant Circuit Pipe: Removal - Refitting
773
Pressure Sensor: Removal - Refitting
775
Duster - Chapitre 7
859
Body Internal Trim
860
Interior Body Side Trim Assembly: Exploded View
860
Roof Trim Assembly: Exploded View
862
Floor Trim Assembly: Exploded View
863
Floor Carpet: Removal - Refitting
864
Windscreen Pillar Trim: Removal - Refitting
867
B-Pillar Trim: Removal - Refitting
868
Front Side Door Trim: Removal - Refitting
871
Side Opening Element Trim
871
Rear Side Door Trim: Removal - Refitting
873
Non-Side Opening Elements Trim
876
Rear Opening Element
876
Front Seat Assembly: Exploded View
877
Front Seat Frames and Mechanisms
877
Duster - Chapitre 8
887
Battery: Precautions for the Repair
891
Battery: Removal - Refitting
892
Headlight Assembly: Exploded View
895
Headlight: Removal - Refitting
896
Headlight: Adjustment
897
Headlight Bulb: Removal - Refitting
899
Front Fog Light Bulb: Removal - Refitting
900
Front Fog Light: Removal - Refitting
901
Side Indicator: Removal - Refitting
902
Remote Headlight Beam Adjustment Actuator: Removal - Refitting
903
Rear Light Assembly: Exploded View
904
Rear Lighting
904
Rear Wing Light: Removal - Refitting
905
Rear Light Bulb: Removal - Refitting
906
3Rd Brake Light: Removal - Refitting
907
High Level Brake Light Bulb: Removal - Refitting
908
Number Plate Light: Removal - Refitting
909
Interior Lighting
910
Interior Lighting: List and Location of Components
910
Radio: List and Location of Components
960
Radio: Removal - Refitting
962
Radio Aerial: Removal - Refitting
963
Front Speakers: Removal - Refitting
964
Rear Speakers: Removal - Refitting
965
Radio Control Satellite: Removal - Refitting
966
Passenger Compartment Connection Unit
967
UCH: Removal - Refitting
967
Electric Window: List and Location of Components
968
Electric Windows - Sunroof
968
Front Electric Window Switch: Removal - Refitting
969
Rear Electric Window Switch: Removal - Refitting
970
Engine Compartment Connection Unit
971
Engine Compartment Connection Unit: List and Location of Components
971
Computers: List and Location of Components
973
Wiring Harness
973
Diagnostic Socket: List and Location of Components
974
Wiring Harness
974
Wiring: Precautions for the Repair
975
Front Bumper Wiring: Removal - Refitting
976
Engine Wiring: Removal - Refitting
977
Passenger Compartment Front Wiring: Removal - Refitting
997
Passenger Compartment Rear
1006
Air Bag and Pretensioners
1014
Airbag and Pretensioners
1015
Airbag and Pretensioners
1016
Airbag Computer: Removal - Refitting
1017
Driver's Frontal Airbag: Removal - Refitting
1019
Passenger's Frontal Airbag: Removal - Refitting
1022
Front (Chest-Level) Side
1025
Side Impact Sensor: Removal - Refitting
1027
Front Seat Belt Buckle: Removal - Refitting
1029
Rear Seat Belt Buckle: Removal - Refitting
1030
Front Side Seat Belt: Removal - Refitting
1031
Rear Side Seat Belt: Removal - Refitting
1035
Section 8
1040
Fault Finding - Introduction
1041
Fault Finding - List and Location of Components
1043
Fault Finding - Role of Components
1044
Fault Finding - Function
1045
Fault Finding - Configuration
1047
Fault Finding - Conformity Check
1048
Fault Finding - Status Summary Table
1050
Fault Finding - Interpretation of Statuses
1051
Fault Finding - Command Summary Table
1060
Fault Finding - Interpretation of Commands
1061
Fault Finding - Customer Complaints
1067
Fault Finding - Fault Finding Chart
1068
Section 9
1101
Access - Safety
1102
Fault Finding - Introduction
1102
Vdiag No.: 09
1102
Fault Finding - List and Location of Components
1108
Fault Finding - Role of Components
1109
Fault Finding - Function
1110
Fault Finding - Configuration
1113
Fault Finding - Programming
1115
Fault Finding - Fault Summary Table
1118
Fault Finding - Interpretation of Faults
1119
Fault Finding - Conformity Check
1123
Fault Finding - Status Summary Table
1126
Fault Finding - Interpretation of Statuses
1127
Fault Finding - Parameter Summary Table
1130
Fault Finding - Interpretation of Parameters
1131
Fault Finding - Command Summary Table
1132
Fault Finding - Interpretation of Commands
1133
Fault Finding - Customer Complaints
1138
Fault Finding - Fault Location Chart
1140
Related product manuals
Renault 2016 Duster
254 pages
Renault Duster
29 pages
Renault Clio 2007
201 pages
Renault Megane 1.9 l dTi
203 pages
Renault Megane 1.9 l dCi
203 pages
Renault Modus
249 pages
Renault Trafic
205 pages
Renault MEGANE
430 pages
Renault KOLEOS
330 pages
Renault Sandero
146 pages
Renault 2012 Clio
24 pages
Renault GRAND SCENIC
24 pages
To Next Page