215916 499 Revision A
Problem Solution
Section
Thermostat defective Contact Dealer.
—
Defective blower switch or
blower motor
Contact Dealer.
—
Partially open, improper ground or
loose connection in compressor
clutch coil
Contact Dealer.
—
Compressor clutch slipping
Contact Dealer.
—
Symptom: Air conditioning system too noisy.
Defective winding or improper
connection in compressor clutch coil
or relay
Contact Dealer.
—
Excessive charge in system
Contact Dealer.
—
Low charge in system
Contact Dealer.
—
Excessive moisture in system
Contact Dealer.
—
Loose or excessively worn drive belt Tighten or replace as required.
Tensioning Air Conditioner Compressor
Belts, page 444 and Replacing Air
Conditioner Compressor Belts, page
445
Noisy clutch
Remove clutch for service or
replacement as required.
Contact Dealer.
Noisy compressor
Check mountings and repair. Remove
compressor for service or
replacement.
Contact Dealer.
Compressor oil level low
Add SP-15 PAG refrigerant oil.
Contact Dealer.
Blower fan noisy due to
excessive wear
Remove blower motor for service or
replacement as necessary.
Contact Dealer.
Symptom: Cab windows fog up.
High humidity
Run A/C to dehumidify air and heater
to control temperature.
3.10.3 Climate Controls, page 59
TROUBLESHOOTING
To Next Page
Loading...
