Dodge Sprinter 2006 - Page 2238

Symptom:
IN PU T S E N S OR MIS MATCH
Wh e n Mo n i to re d a n d S e t Co n d it i o n :
IN PU T S E N S OR MIS MATCH
Wh en Mon itor ed: E ngin e speed gr ea ter t h a n 450 r pm , no en gin e speed DTC’s, no TCM
un der-volta ge system oper at ion , n o ou t put speed sen sor DTC’s (sign al fr om t h e ABS
syst em ), all wh eel speeds a bove 250 rpm (sign al fr om t he ABS syst em ), n o r ea r wh eel speed
DTC’s (sign a l fr om t h e ABS system ), a nd n o wh eel slip det ect ed (sign al fr om t h e ABS
syst em ), no sh ift in g oper at ion , N3 in pu t speed sen sor gr ea t er t h an 800 rpm a n d N2 inpu t
speed sensor gr ea ter t h an 0 r pm a n d t h e TCM n ot in r eset .
Set Condit ion : If t h e speed differ en ce bet ween t h e N2 a n d N3 in pu t speed sen sors is
gre a ter than 15 0 rp m.
POSSIBLE CAUSES
SPEE D SENSOR DTCS PRESENT
IN TE RMITTE NT WIRING AND CONNECTORS
IN TE RN AL TRANSMISSION
TCM - IN P UT SP E E D SE N SOR MI SMATCH
TE S T ACTION AP PLICAB ILITY
1 NOTE: Low fluid level can be the cause of many transmission problems. If
the fluid level is low locate and repair the leak then check and adjust the
flui d lev el p er t h e s e r vi c e i n fo r m a ti o n .
NOTE: Always perform diagnostics with a fully charged battery to avoid
fa ls e s y m p t o m s .
Wit h t h e DRBIII#, r ea d t h e en gin e DTCs. Ch eck a n d r epa ir all en gin e DTCs pr ior to
per for m in g t r a n sm ission sympt om dia gnost ics.
Wit h th e DRBIII#, r ea d a n d recor d a ll Tra n sm ission DTCs.
NOTE: Ch e c k c o n n e c to rs - Cle a n /re pa i r a s n e c e s s a ry. P o o r p in to te rm in a l
connections can set DTCs.
Usin g t h e wir in g dia gr a m /schem a t ic a s a gu ide, in spect t he wir in g a n d con n ect or s.
Repa ir a s n ecessa r y.
Most DTCs set on st a r t up bu t som e m u st be set by dr iving th e veh icle su ch t h a t a ll
dia gnost ic m on itor s h a ve r u n .
Note: Verify flash level of transmission controller. Some problems are
corrected by software upgrades to the transmission controller.
NOTE: Ch e c k fo r a n y Te ch n ic a l S e rv ic e B u lle t in s th at m a y ap p ly.
Per for m t h is pr ocedu r e pr ior to Sym pt om dia gn osis.
All
Con t in u e
Go To 2
78
TRANSMISSION - NAG1