9980 Self-Propelled Peanut Combine Introduction
MAN141.rev1 08/05/16 iii
7. Calibration ........................................ 127
When to Calibrate ............................. 128
Error Codes ...................................... 128
Calibration Procedures ..................... 129
8. Cab Climate Control ........................ 131
System Overview .............................. 132
Sensors Monitored ........................ 132
CLIMATRAK Inlet Panel ................ 133
CLIMATRAK Precleaner ............... 133
Filters ............................................... 134
Fresh Air Filter .............................. 134
Recirculating Filter ........................ 135
Cleaning Filters ............................. 136
Troubleshooting ................................. 137
CLIMATRAK High Pressure Switch137
CLIMATRAK Low Pressure Switch 137
9. Lights and Signals ........................... 139
General Information .......................... 140
Cab Interior Light ........................... 141
Turn Signals .................................. 142
Stop Lights .................................... 143
Light Switches .................................. 144
Dimmer Switch .............................. 145
Hazard Lights ................................ 146
Road Lights ................................... 147
Field Lights .................................... 148
Field Lights/Side Finder Lights.. 149
Stubble and Rear Residue Lights .. 150
Service Lighting ................................ 151
Engine Compartment Light ............ 151
Service Lights ............................... 151
Service Light Locations............. 152
Exit Lights ..................................... 153
10. Prestarting Checks ......................... 155
Read First ......................................... 156
Breaking in the Engine ...................... 157
First 50 Hours ............................... 158
Belt Drives Adjustment ............. 158
First 100 Hours ............................. 158
Break-in Check ......................... 158
Pre-start Daily Checks ...................... 159
Engine Oil ..................................... 159
Temperature ................................. 160
Hydrostatic/Hydraulic Oil Level ...... 161
Coolant Level ................................ 162
Fuel System .................................. 163
Fuel Tank Breather ....................... 164
Cleaning Engine Compartment ..... 164
Tires ............................................. 165
After Long Storage ....................... 165
11. Operation ........................................ 167
General Operation ........................... 168
Starting the Engine ....................... 168
Stopping the Engine ..................... 171
Cold Weather Operation .................. 172
Fuel Tank ..................................... 172
Fuel Tank Breather ....................... 172
Radiator ....................................... 173
Batteries ....................................... 174
Glow Plugs ................................... 175
Coolant Heater ............................. 176
Hot Weather Operation .................... 177
12. Transportation ............................... 179
Before Transporting ......................... 180
Driving the Combine on Roads ........ 181
Back-Up Alarm ............................. 185
Towing the Combine ........................ 186
Rear Tow Hook ............................ 187
Four-Wheel Drive ............................. 188
Read First ..................................... 188
Using Four-Wheel Drive ............... 189
13. Unloading Conveyor ...................... 191
Before Using the Conveyor .............. 192
Conveyor Safety ........................... 192
Using the Conveyor ......................... 193
Conveyor Tracking ........................... 195
Conveyor Maintenance .................... 196
Conveyor Troubleshooting ............... 197
Conveyor Timing .............................. 198
14. Performance ................................... 199
Cleaning Fan Damper ...................... 200
Overhead Teeth ............................... 202
Retention Board ............................... 203
Concave Teeth ................................ 204
10% Speed Control .......................... 205
Threshing Speed ............................. 206
Header Speed Control ..................... 207
Header Height Control ..................... 208
Elevator Fan Damper ....................... 209
Dual Speed Picking Cylinder Drive .. 210
15. Engine............................................. 211
Compartment ................................... 213
Rear Ladder and Landing ............. 213
Engine Access Covers ................. 213
To Next Page
Loading...