1D-0 - IMPORTANT INFORMATION 90-824052R3 JUNE 2002
Table of Contents
Page
Notice to Installer and Owner 1D-1. . . . . . . . . . . . . .
Boat Horsepower Capacity 1D-1. . . . . . . . . . . . . . . .
Outboard Remote Control 1D-1. . . . . . . . . . . . . . . . .
Selecting Accessories For The Outboard 1D-1. . . .
Selecting Steering Cables and Remote
Control Cables 1D-1. . . . . . . . . . . . . . . . . . . . . . . . .
Determining Recommended Outboard
Mounting Height 1D-2. . . . . . . . . . . . . . . . . . . . . . .
Locating Centerline of Boat Transom 1D-3. . . . . . .
Drilling Outboard Mounting Holes 1D-3. . . . . . . .
Applying Counter Rotation Decals 1D-3. . . . . . .
Lifting Outboard 1D-4. . . . . . . . . . . . . . . . . . . . . . . . . .
Installing Outboard To Boat Transom 1D-4. . . . . . .
Single Steering Cable and Steering Link
Rod Installation 1D-5. . . . . . . . . . . . . . . . . . . . . . . .
Installing Ride Guide Cable to Outboard
Tilt Tube 1D-5. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Link Rod Installation 1D-5. . . . . . . . . . .
Routing Location for Wiring and Hoses thru
Clamp in Bottom Cowl 1D-6. . . . . . . . . . . . . . . . . .
Remote Control Installation 1D-6. . . . . . . . . . . . . . . .
Counter (Left Hand) Rotation Outboards 1D-6. .
Required Side Mount Remote Control or Ignition
Key Switch Assembly 1D-7. . . . . . . . . . . . . . . . . . .
Boats Equipped with Side Mount
Remote Control 1D-7. . . . . . . . . . . . . . . . . . . . .
Boats Equipped with Panel or Console
Mount Remote Control 1D-7. . . . . . . . . . . . . . .
Page
Shift and Throttle Cable Installation to
the Outboard 1D-7. . . . . . . . . . . . . . . . . . . . . . . . . .
Shift Cable Installation 1D-7. . . . . . . . . . . . . . . . .
Throttle Cable Installation 1D-8. . . . . . . . . . . . . . .
Remote Wiring Connections 1D-9. . . . . . . . . . . . . . .
Battery Connections 1D-9. . . . . . . . . . . . . . . . . . . . . .
Fuel Connections 1D-10. . . . . . . . . . . . . . . . . . . . . . .
Connecting Fuel Hose to Engine 1D-10. . . . . . . .
Portable Fuel Tank 1D-10. . . . . . . . . . . . . . . . . . . .
Permanent Fuel Tank 1D-10. . . . . . . . . . . . . . . . .
Fuel Line 1D-10. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Set Up Instructions for Oil Injection System 1D-10.
Installing Remote Oil Tank 1D-10. . . . . . . . . . . . .
Installing Oil Hoses To Engine 1D-11. . . . . . . . . .
Filling the Oil Injection System 1D-11. . . . . . . . . .
Bleeding Air from Oil Injection Pump and
Oil Injection Outlet Hose 1D-12. . . . . . . . . . . . .
Adjusting Oil Injection Pump 1D-12. . . . . . . . . . .
Propeller Selection 1D-12. . . . . . . . . . . . . . . . . . . . . .
Propeller Installation 1D-12. . . . . . . . . . . . . . . . . . . . .
Power Trim System 1D-13. . . . . . . . . . . . . . . . . . . . . .
General Information 1D-13. . . . . . . . . . . . . . . . . . .
Power Trim Operation 1D-13. . . . . . . . . . . . . . . . .
Trim “IN” Angle Adjustment 1D-14. . . . . . . . . . . .
Checking Trim System Fluid Level 1D-14. . . . . .
Trim Tab Adjustment 1D-14. . . . . . . . . . . . . . . . . . . . .