9980 Self-Propelled Peanut Combine Safety
Service Accumlator Systems
Safety
• Escaping fluid or gas from pressurized
hydraulic accumulator systems can
cause serious injury.
• Extreme heat can cause the
accumulator to burst, and pressurized
lines can be accidentally cut.
• Do NOT weld or use a torch near a
pressurized accumulator or pressurized
line.
• Relieve pressure from the hydraulic
system before removing the
accumulator.
• Never attempt to relieve a hydraulic
system or accumulator pressure by
loosening a fitting.
• Accumulators cannot be repaired.
Sulfuric acid in battery electrolyte is
poisonous. It is a strong enough to burn
skin, eat holes in clothing, and cause
blindness if splashed into eyes.
To avoid the hazard:
• Fill batteries in a well-ventilated area.
• Wear eye protection and rubber gloves.
• Avoid breathing fumes when adding
electrolyte.
• Use proper jump start procedure.
If you spill acid on yourself:
• Flush your skin with water.
• Apply baking soda or lime to help
neutralize the acid.
• Flush your eyes with water for 15-30
minutes. Get the medical attention
immediately.
If acid is swallowed:
• Do NOT induce vomiting.
• Drink large amounts of water or milk, but
do not exceed 2 L (2 quarts).
• Get medical attention immediately.
Prevent Machine Damage When
Welding
To prevent damage to electronic
components, be sure to disconnect the
negative ground cable before welding on
combine.
MAN141 09/16/15 13
To Next Page
Loading...