Daedong CK22 - Changing Engine Oil; Checking Fuel Line; Every 100 Hours

1-17
DS35-W00 May. 2007
CLUTCHCLUTCH CLUTCHCLUTCH
CLUTCH
TRANSMISSIONTRANSMISSION TRANSMISSIONTRANSMISSION
TRANSMISSION
ENGINEENGINE ENGINEENGINE
ENGINE
HSTHST HSTHST
HST
FRONT AXLEFRONT AXLE FRONT AXLEFRONT AXLE
FRONT AXLE
STEERINGSTEERING STEERINGSTEERING
STEERING
BARKEBARKE BARKEBARKE
BARKE
ELECTRICELECTRIC ELECTRICELECTRIC
ELECTRIC
INDEXINDEX INDEXINDEX
INDEX
HYDRAULICHYDRAULIC HYDRAULICHYDRAULIC
HYDRAULIC
GENERALGENERAL GENERALGENERAL
GENERAL
REAR AXLEREAR AXLE REAR AXLEREAR AXLE
REAR AXLE
CK22/CK22H
8.3 EVERY 100 HOURS
8.3.1 CHANGING ENGINE OIL
(1) Oil inlet
(2) Dipstick
(a) Oil level is acceptable within this range
196W125A
(1) Drain plug
1. To drain the used oil, remove the drain plug at the
bottom of the engine and drain the oil completely
into the oil pan.
All the used oil can be drained out easily when the
engine is still warm.
2. After draining reinstall the drain plug.
3. Fill with the new oil up to the upper notch on the
dipstick.
196W126A
8.3.2 CHECKING FUEL LINE
1. Check to see that all lines and hose clamps are
tight and not damaged.
2. If hoses and clamps are found worn or damaged,
replace or repair them at once.
NOTE:
• If the fuel line is removed, be sure to properly bleed
the fuel system. (See chapter 3.4)
(1) Fuel lines (2) Clamp bands
196W131B
To avoid personal injury:
• Be sure to stop the engine before changing the oil.
• Allow engine to cool down sufficiently, oil can be
hot and can burn.
CAUTION
Oil capacity with filter
2.6
(0.69 U.S.gal.)
GENERAL - CHECK AND MAINIENANCE