Daedong CK22 - Bleeding Fuel System; Draining Clutch Housing Water; Replacing Light Bulb; Service as Required

1-30
DS35-W00 May. 2007
CLUTCHCLUTCH CLUTCHCLUTCH
CLUTCH
TRANSMISSIONTRANSMISSION TRANSMISSIONTRANSMISSION
TRANSMISSION
ENGINEENGINE ENGINEENGINE
ENGINE
HSTHST HSTHST
HST
FRONT AXLEFRONT AXLE FRONT AXLEFRONT AXLE
FRONT AXLE
STEERINGSTEERING STEERINGSTEERING
STEERING
BARKEBARKE BARKEBARKE
BARKE
ELECTRICELECTRIC ELECTRICELECTRIC
ELECTRIC
INDEXINDEX INDEXINDEX
INDEX
HYDRAULICHYDRAULIC HYDRAULICHYDRAULIC
HYDRAULIC
GENERALGENERAL GENERALGENERAL
GENERAL
REAR AXLEREAR AXLE REAR AXLEREAR AXLE
REAR AXLE
CK22/CK22H
1
8.10 SERVICE AS REQUIRED
8.10.1 BLEEDING FUEL SYSTEM
Air must be removed:
1. When the fuel filter or lines are removed.
2. When tank is completely empty.
3. After the tractor has not been used for a long period
of time.
Bleeding procedure is as follows:
1. Fill the fuel tank with fuel, and open the fuel cock.
2. Loosen the air vent bolt on the fuel injection pump.
3. Start the engine and run for about 30 seconds, and
then stop the engine.
4. Tighten the air vent bolt.
(1) Fuel cock (A) Close
(B) Open
(1) Split pin plugs
8.10.2 DRAINING CLUTCH HOUSING WATER
The tractor is equipped with split pin plug under the
clutch housing.
After operating in rain, snow or tractor has been
washed, water may get into the clutch housing. Check
it by pushing in the split pin.
If water enters into the clutch housing, remove the plug
and drain the water, then reinstall the plug.
8.10.3 REPLACING LIGHT BULB
1. Head lights and rear combination lights:
Take the bulb out of the light body and replace with
a new one.
2. Other lights:
Detach the lens and replace the bulb.
196W153A
196W154A
• Always close the air vent cock except for bleed-
ing fuel lines.
• Otherwise, engine runs irregularly or stalls
frequently.
IMPORTANT
CapacityLight
35 W / 35 W
10 W
21 W
21 W
21 W
3.4 W
Head lights
Tail lights
Stop lights
Turn signal lights
Work light (Option)
Instrument panel light
1
2
3
4
5
6
CK22-USA
Capacity
Light
55 W / 60 W
21 W
21 / 5 W
21 W
21 W
3.4 W
Head lights
Front Position lights
Stop / Rear Position lights
Turn signal lights
Work light
Instrument panel light
1
2
3
4
5
6
196W168B
GENERAL - CHECK AND MAINIENANCE