Daedong CK22 - Every 2 Years; Flush Cooling System and Changing Coolant; Once a Year; Replacing Air Cleaner Element

1-28
DS35-W00 May. 2007
CLUTCHCLUTCH CLUTCHCLUTCH
CLUTCH
TRANSMISSIONTRANSMISSION TRANSMISSIONTRANSMISSION
TRANSMISSION
ENGINEENGINE ENGINEENGINE
ENGINE
HSTHST HSTHST
HST
FRONT AXLEFRONT AXLE FRONT AXLEFRONT AXLE
FRONT AXLE
STEERINGSTEERING STEERINGSTEERING
STEERING
BARKEBARKE BARKEBARKE
BARKE
ELECTRICELECTRIC ELECTRICELECTRIC
ELECTRIC
INDEXINDEX INDEXINDEX
INDEX
HYDRAULICHYDRAULIC HYDRAULICHYDRAULIC
HYDRAULIC
GENERALGENERAL GENERALGENERAL
GENERAL
REAR AXLEREAR AXLE REAR AXLEREAR AXLE
REAR AXLE
CK22/CK22H
1. Stop the engine and let cool down.
2. To drain the coolant, open the radiator drain plug
and remove radiator cap. The radiator cap must be
removed to completely drain the coolant.
3. After all coolant is drained, close the drain plug.
4. Fill with clean water and cooling system cleaner.
5. Follow directions of the cleaner instruction.
6. After flushing, fill with clean water and anti-freeze
until the coolant level is just below the port.
Install the coolant up to the “FULL” mark on the re-
covery tank.
7. Fill with coolant up to the “FULL” mark on the recov-
ery tank.
8. Start and operate the engine for few minutes.
9. Stop the engine and let cool.
10. Check coolant level of recovery tank and add cool-
ant if necessary.
8.9 EVERY 2 YEARS
8.9.1 FLUSH COOLING SYSTEM AND
CHANGING COOLANT
(1) Drain plug
(1) Radiator cap (A) FULL
(2) Recovery tank (B) LOW
196W152A
196W151B
8.8 ONCE A YEAR
8.8.1 REPLACING AIR CLEANER ELEMENT
(See “Cleaning Air Cleaner Element” in every 100 hours
maintenance.)
• Do not start engine without coolant.
• Use clean, fresh water and anti-freeze to fill the
radiator and recovery tank.
• When the anti-freeze is mixed with water, the anti-
freeze mixing ratio must be less than 50 %.
• Securely tighten radiator cap. If the cap is loose
or improperly fitted, water may leak out and the
engine could overheat.
IMPORTANT
To avoid personal injury:
• Do not remove the radiator cap when the engine
is hot. Then loosen cap slightly to the stop the
relieve any excess pressure before removing cap
completely.
CAUTION
Coolant capacity
5.7 (1.50 U.S.gal.)
GENERAL - CHECK AND MAINIENANCE