MacDon M205 - Battery Safety

214603 8 Revision A
1.7 Battery Safety
1000015
Figure 1.16: Safety around Batteries
WARNING
• Keep all sparks and flames away from batteries, as a
gas given off by electrolyte is explosive.
• Ventilate when charging in enclosed space.
1000016
Figure 1.17: Safety around Batteries
WARNING
• Wear safety glasses when working near batteries.
• Do NOT tip batteries more than 45° to avoid
electrolyte loss.
• Battery electrolyte causes severe burns. Avoid
contact with skin, eyes, or clothing.
• Electrolyte splashed into eyes is extremely
dangerous. Should this occur, force eye open, and
flood with cool, clean water for 5 minutes. Call a
doctor immediately.
• If electrolyte is spilled or splashed on clothing or
body, neutralize it immediately with a solution of
baking soda and water, then rinse with clear water.
1000017
Figure 1.18: Safety around Batteries
WARNING
• To avoid injury from spark or short circuit, disconnect
battery ground cable before servicing any part of
electrical system.
• Do NOT operate engine with alternator or battery
disconnected. With battery cables disconnected and
engine running, a high voltage can be built up if
terminals touch frame. Anyone touching frame under
these conditions would be severely shocked.
• When working around storage batteries, remember
that all of the exposed metal parts are live. Never lay a
metal object across terminals because a spark or
short circuit will result.
• Keep batteries out of reach of children.
SAFETY