MacDon M205 - Chapter 6: Troubleshooting; Engine Troubleshooting

214603 421 Revision A
6 Troubleshooting
6.1 Engine Troubleshooting
Symptom
Problem
Solution Reference
Engine hard to
start or will
not start
Controls not in NEUTRAL Move GSL to NEUTRAL.
Starting the
Engine, page 164
Engine hard to
start or will
not start
Controls not in NEUTRAL
Move steering wheel to locked
position.
Starting the
Engine, page 164
Engine hard to
start or will
not start
Controls not in NEUTRAL
Disengage header drive switch.
4.4.4 Header
Drive, page 204
Engine hard to
start or will
not start
NEUTRAL Interlock
misadjusted
Contact Dealer. Contact Dealer
Engine hard to
start or will
not start
No fuel to engine
Fill empty fuel tank. Replace clogged
filter.
Filling the Fuel
Tank, page 167
and Maintaining
Fuel Filters, page
324
Engine hard to
start or will
not start
Old fuel in tank Drain tank. Refill with fresh fuel.
5.8.5 Fuel System,
page 323
Engine hard to
start or will
not start
Water, dirt, or air in fuel
system
Drain, flush, fill, and prime system.
5.8.5 Fuel System,
page 323
Engine hard to
start or will
not start
Improper type of fuel
Use proper fuel for operating
conditions.
8.2.2 Fuel
Specifications,
page 460
Engine hard to
start or will
not start
Crankcase oil too heavy
Use recommended oil.
8.2.3 Lubricants,
Fluids, and System
Capacities, page
461
Engine hard to
start or will
not start
Low battery output
Have battery tested. Check battery
electrolyte level.
5.9.2 Battery, page
349
Engine hard to
start or will
not start
Poor battery connection
Clean and tighten loose connections.
5.9.2 Battery, page
349
Engine hard to
start or will
not start
Faulty starter
Contact Dealer. Contact Dealer
Engine hard to
start or will
not start
Loose electrical connection at
fuel pump
Ensure connector at pump is fully
pushed in.
Contact Dealer