SHOP MANUAL
GENERAL INSTRUCTIONS
Ch 0 page 16
The machine and some attachments have components that reach
high temperatures under normal operating conditions. The primary
source of high temperatures are the engine and exhaust system. If
damaged or incorrectly maintained, the electrical system can be a
source of arcs or sparks. Flammable debris (leaves, straw, etc.) must
be removed regularly. If flammable debris is allowed to accumulate, it
can cause a fire hazard. Clean machine often to avoid this accumula-
tion. Flammable debris in an engine compartment is a potential fire
hazard. The operator's area, engine compartment and engine cooling
system must be inspected every day and cleaned. This is necessary
to prevent fire hazards and overheating.
Maintenance
Do not use machine where exhaust, arcs, sparks or hot components
can contact flammable material, explosive dust or gases. Do not oper-
ate machine near any flame. Exhaust shields (if equipped) protect hot
exhaust components from oil spray or fuel spray in case of a break in
a line, hose, or seal. Exhaust shields must be correctly installed and
maintained properly.
Electrical
Operation
Check all electrical wiring and connections for damage daily. Keep
battery terminals clean and tight. Repair or replace any damaged
parts or wires that are loose or frayed. Clean all electrical connections
and tighten all electrical connections. Never check battery charge by
placing a metal object across terminal posts. Use a voltmeter or a hy-
drometer. Battery gas can explode and can result in death or serious
injury.
Follow procedures in this manual for connecting battery and for jump-
starting. Do not jump-start or charge a frozen or damaged battery.
Keep all flames and sparks away from batteries. Do not smoke in
battery charging area. Improper jumper cable connections can cause
an explosion that can result in death or serious injury. Refer to Opera-
tion and Maintenance Manual for proper procedure in this manual. Do
not charge a frozen battery. This can cause an explosion. After market
radios or other electric operated equipment in cabin must have a fuse
in the electrical circuit.
To Next Page
Loading...