MCE iControl User Manual

iControl Messages
6-35
6
iControl DC
Excessive Relevels Fault, EXCESS RELEVELS FAULT
Description: The car has failed to relevel after ten attempts.
Car Reaction: Cancel all calls and shutdown. The doors are cycled and the car remains shutdown until the
fault is reset by pressing the iBox Fault Reset button, toggling Inspection or cycling power to the controller.
Troubleshooting:
1. Check for mechanical or other failure preventing proper releveling.
2. Adjust brake and motor control during releveling with a full load in the car.
Excessive Restarts Fault, EXCESS RESTARTS FAULT
Description: The elevator has attempted to start movement from the same floor successively for an exces-
sive number of times. This fault is issued after twenty-five attempts. The counter is reset if the car makes
one successful run.
Car Reaction: Cancel all calls and shutdown. The doors are cycled and the car remains shutdown for five
minutes after the first fault or until the fault is reset by pressing the iBox Fault Reset button, toggling Inspec-
tion or cycling power to the controller.
Troubleshooting:
1. Check for mechanical or other failure preventing car from moving away from floor the floor.
Excessive Restarts Warning
Description: The elevator has attempted to start movement from the same floor successively for an exces-
sive number of times. This fault is issued after ten attempts. The counter is reset if the car makes one suc-
cessful run.
Car Reaction: None.
Troubleshooting:
1. Check for mechanical or other failure preventing car from moving away from floor the floor.
Exercise Operation Activated, EXERCISE OPERATION
Description: The car has been idle for a predetermined user-defined time and is now performing a user-
defined number of Exercise operation runs.
Car Reaction: The car lowers to the bottom landing, then proceeds to the top landing and back down to the
bottom landing without cycling the doors. Moving the car to the top landing and then back down to the bot-
tom landing is considered one exercise run. The user defines the number of exercise runs.
Exercise Operation Deactivated
Description: The car has completed all of the exercise runs or Exercise operation has been terminated due to
change in mode of operation or calls being entered into the system.
Fault Bypass Switch On, FAULT BYPASS SW ON
Description: The iBox Fault Bypass switch is in the ON position.
Car Reaction: None.
Fault Bypass Switch Timed Out, FLT BYP SW TIMED OUT
Description: Indicates that a fault bypass has timed out. (Bypasses are allowed for 15 minutes with the iBox
Fault/Function Bypass switch in the ON position.)
Car Reaction: Emergency stop: Motor contactor and brake contactor immediately dropped.
Troubleshooting:
1. To clear this fault, place the Fault/Function Bypass switch to the OFF position.
F DPM OPEN-GS CLOSED. See Front DPM Open - GS Closed.
F DR CLS FLT REC FAIL. See Front Door Close Fault Recovery Failure
Table 6.3 iControl Messages
iControl Messages

MCE iControl Specifications

General

Brand	MCE
Model	iControl
Category	Controller
Language	English