Chrysler 2000 LHS User Manual

BODY COMPONENTS
TABLE OF CONTENTS
page page
DIAGNOSIS AND TESTING
WATER LEAKS ..........................31
WIND NOISE............................32
SERVICE PROCEDURES
HEAT STAKING ..........................32
PLASTIC BODY PANEL REPAIR..............32
REMOVAL AND INSTALLATION
UPPER RADIATOR CLOSURE PANEL .........37
HOOD LATCH ...........................38
HOOD RELEASE CABLE ...................38
HOOD GAS PROPS.......................39
HOOD .................................39
HOOD HINGE ...........................40
COWL SCREEN ..........................41
GRILLE - CONCORDE .....................41
GRILLE - UPPER - 300M ...................41
GRILLE - LOWER - 300M...................42
EXTERIOR BADGEING ATTACHED WITH
DOUBLE SIDED FOAM TAPE ..............42
EXTERIOR BADGEING/TAPE STRIPES
ATTACHED WITH ADHESIVES .............42
WHEELHOUSE SPLASH SHIELD – FRONT .....42
FENDER ...............................43
FRONT STRUT TOWER TO TOWER BRACE ....43
FRONT DOOR FLAG ENCLOSURE COVER/
PLATE................................43
FRONT DOOR TRIM PANEL ................44
FRONT AND REAR DOOR WATER DAM .......45
FRONT DOOR LATCH .....................45
OUTSIDE FRONT DOOR HANDLE............46
DOOR LOCK CYLINDER ...................46
LOCK CYLINDERS........................46
FRONT DOOR LATCH STRIKER .............46
FRONT DOOR GLASS RUN WEATHERSTRIP . . . 47
FRONT DOOR WINDOW FRAME MOLDING ....48
FRONT DOOR GLASS .....................48
FRONT DOOR GLASS REGULATOR ..........48
FRONT DOOR CHECK STRAP ..............49
FRONT DOOR ...........................49
FRONT DOOR HINGE .....................50
DOOR HINGE DOUBLE ENDED STUD.........50
FRONT DOOR BODY MOUNTED
WEATHERSTRIP........................51
FRONT DOOR MOUNTED WEATHERSTRIP ....51
REAR DOOR TRIM PANEL..................51
REAR DOOR LATCH ......................52
REAR DOOR LATCH STRIKER ..............53
REAR DOOR GLASS RUN WEATHERSTRIP ....54
REAR DOOR GLASS REGULATOR ...........54
REAR DOOR GLASS ......................55
REAR DOOR SAIL PANEL ..................55
REAR DOOR CHECK STRAP................55
REAR DOOR............................56
REAR DOOR HINGE ......................56
REAR DOOR MOUNTED WEATHERSTRIP .....57
REAR DOOR BODY MOUNTED
WEATHERSTRIP........................57
BODY SIDE MOLDING AND APPLIQUE ........58
WHEELHOUSE SPLASH SHIELD – REAR ......58
DECKLID COVER.........................58
DECKLID LATCH .........................59
DECKLID LOCK CYLINDER .................59
DECKLID LATCH STRIKER .................60
DECKLID GAS PROPS.....................60
DECKLID ...............................60
DECKLID HINGE .........................61
DECKLID SLAM BUMPER ..................61
DECKLID WEATHERSTRIP .................61
DRIP RAIL WEATHERSTRIP ................61
DOOR SILL TRIM.........................62
A-PILLAR TRIM ..........................62
CROSS CAR BEAM .......................62
B-PILLAR LOWER TRIM....................63
B-PILLAR UPPER TRIM ....................63
QUARTER TRIM LOWER (C-PILLAR)..........64
QUARTER TRIM UPPER (C-PILLAR) ..........64
FRONT SEAT BELT RETRACTOR ............64
FRONT SEAT CENTER OCCUPIED BELT
BUCKLE – CONCORDE/INTREPID ..........65
REAR SEAT BELT RETRACTOR .............65
REAR SEAT BELT BUCKLE .................66
FLOOR CONSOLE ARMREST LID ............66
FLOOR CONSOLE ARMREST LATCH .........66
FLOOR CONSOLE END CAP................66
FLOOR CONSOLE ........................67
FLOOR CONSOLE SHIFT BEZEL.............69
FLOOR CONSOLE CUP HOLDER ASSEMBLY . . . 69
FRONT FLOOR CONSOLE PANEL –
CONCORDE ...........................69
FRONT FLOOR CONSOLE SIDE PANEL –
INTREPID, LHS, 300M....................70
FLOOR CARPET .........................71
SUN VISOR .............................71
FRONT ASSIST HANDLE ...................71
REAR ASSIST HANDLE AND READING LAMP. . . 72
HEADLINER.............................72
ROOF STRUCTURAL MEMBRANE............73
REAR SHELF TRIM PANEL .................74
23 - 30 BODY LH

Chrysler 2000 LHS Specifications

General

Brand	Chrysler
Model	2000 LHS
Category	Automobile
Language	English