Xerox DocuColor 2240 - Page 196

09/03
2-163
DC 3535/2240/1632, WC M24
8-175
Status Indicator RAPs
Initial issue
8-175 Registration Sensor On Jam Tray 5
The Registration Sensor does not detect paper fed from the MSI.
Initial Actions
• Check condition and specification of the paper supply.
• Check for obstructions in the paper feed path.
• Clean the MSI Feed Roll and check for wear.
• Clean the Takeaway Roll and check for wear.
• Check the drive transmissions for damage or wear.
• Push down on the Bottom Plate (PL 2.14) and release it, check that the springs return the
Bottom Plate to its upper position. Check for weak or damaged spring/s.
Procedure
Open the Left Cover Assembly (PL 2.9). Enter dC330 [008-104] and press Start. Block and
unblock the Registration Sensor (PL 2.6). The display changes state.
YN
Press Stop. Check the circuit of the Registration Sensor (Figure 1). Refer to the OF 99-1
RAP for troubleshooting procedure.
The machine is a DC3535.
YN
Close the Left Cover Assembly and press Stop. Enter dC330 [007-003] and press Start.
The Tray 5 Feed Solenoid (PL 2.14) energizes.
YN
Press Stop. Check the circuit of the Tray 5 Feed Solenoid (Figure 2). Refer to the
OF 99-4 RAP for troubleshooting procedure.
Press Stop.
• Ensure that the connectors shown in the circuit diagrams (Figure 1, Figure 2) are
securely connected and that the wires are not damaged.
• Replace the Registration Sensor (PL 2.6).
• If the problem persist, replace the ESS PWB (PL 13.1).
Close the Left Cover Assembly and press Stop. Enter dC330 [007-003] and press Start. The
Tray 5 Feed Solenoid (PL 2.14) energizes.
YN
Press Stop. Check the circuit of the Tray 5 Feed Solenoid (Figure 3). Refer to the OF 99-
4 RAP for troubleshooting procedure.
Press Stop.
• Ensure that the connectors shown in the circuit diagrams (Figure 1, Figure 3) are securely
connected and that the wires are not damaged.
• Replace the Registration Sensor (PL 2.6).
• If the problem persists, replace the ESS PWB (PL 13.1).
Figure 1 8-175 RAP Circuit Diagram - Registration Sensor
Figure 2 8-175 RAP Circuit Diagram - DC2240/1632 Tray 5 Feed Solenoid
Figure 3 8-175 RAP Circuit Diagram - DC3535 Tray 5 Feed Solenoid