Home
Xerox
All in One Printer
WorkCentre 7132
Xerox WorkCentre 7132 Service Documentation
4
of 1
of 1 rating
1726 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Janu
ary 2007
2-44
5
WorkCent
re 7
132
034-71
5, 034-
716
St
atus-in
dicator-
rap
s
Revisio
n
034-
715 Fa
x Comm
unic
ation
RAP
There
is a wai
t re
lease co
mplete
time-
out.
Proc
edure
Ask custom
er to
cancel t
he job
and r
esend.
034-71
6 Fax Comm
unicat
ion RAP
There i
s a connection
time-out.
Proc
edure
Ask
custom
er to
cancel
the j
ob and r
esend
.
477
479
Table of Contents
WC 7132 Service Manual
2
Introduction
2
About this Manual
4
Organization
4
How to Use this Documentation
5
Symbology and Nomenclature
6
Translated Warnings
9
Introdution
10
1 Service Call Procedures
16
Service Call Procedures
18
Initial Actions
18
Call Flow
19
Detailed Maintenance Activities (HFSI)
21
Cleaning Procedures
22
Final Actions
22
2 Status Indicator RAPs
24
Chain 001
40
Power On RAP
40
Chain 002
42
002-770 Job Template Processing - HDD Full RAP
42
Chain 003
44
003-318 IIT Software RAP
44
003-319 IIT Video Driver Detection RAP
44
003-320 IISS-ESS Communication 1 RAP
45
003-321 IISS-ESS Communication 2 RAP
45
003-322 IISS-ESS Communication 3 RAP
46
003-323 IISS-ESS Communication 4 RAP
46
003-324 IISS-ESS Communication 5 RAP
47
003-325 IISS-ESS Communication 6 RAP
47
003-326 IISS-ESS Communication 7 RAP
48
003-327 IISS-ESS Communication 8 RAP
48
003-328 IISS-ESS Communication 9 RAP
49
003-329 IISS-ESS Communication 10 RAP
49
003-330 IISS-ESS Communication 11 RAP
50
003-331 IISS-ESS Communication 12 RAP
50
003-332 IISS-ESS Communication 13 RAP
51
003-333 IISS-ESS Communication 14 RAP
51
003-334 IISS-ESS Communication 15 RAP
52
003-335 IISS-ESS Communication 16 RAP
52
003-336 IISS-ESS Communication 17 RAP
53
003-337 IISS-ESS Communication 18 RAP
53
003-338 IISS-ESS Communication 19 RAP
54
003-339 IISS-ESS Communication 20 RAP
54
003-340 IISS-ESS Communication 21 RAP
55
003-341 IISS-ESS Communication 22 RAP
55
003-342 IISS-ESS Communication 23 RAP
56
003-343 IISS-ESS Communication 24 RAP
56
003-344 Hotline Power On
57
003-345 PIO Unlatched 1 RAP
57
003-346 PIO Unlatched 2 RAP
58
003-750 Book Duplex Documents RAP
58
003-751 Panther Capacity RAP
59
003-754 S2X Recovery RAP
59
003-755 S2X Command Error RAP
60
003-756 Blank Originals RAP
60
003-760 Scan Settings RAP
61
003-761 Incorrect Paper Tray Size RAP
61
003-763 Adjustment Chart RAP
62
003-764 Image Overlay RAP
62
003-780 Scanned Image Compression RAP
63
003-795 AMS Limit RAP
63
003-930 300 DPI Scan RAP
64
003-931 400 DPI Scan RAP
64
003-932 600 DPI Scan RAP
65
003-933 300 DPI Scan RAP
65
003-934 400 DPI Scan RAP
66
003-935 600 DPI Scan RAP
66
003-940 Memory RAP
67
003-942 Document Size Auto Detect RAP
67
003-944 Image Repeat Count RAP
68
003-946 Image Rotation (Copy APS) RAP
68
003-947 Return Documents Count RAP
69
003-948 Return Documents Mismatch RAP
69
003-952 Document Color Mismatch RAP
70
003-955 Documents Size Exchange RAP
70
003-956 Coping from the Platen Failure RAP
71
003-963 APS Object Tray RAP
71
003-965 ATS/APS Paper Detect RAP
72
003-966 ATS/APS Destination (IIT) RAP
72
003-970 Fax Line Memory RAP
73
003-972 Maximum Stored Page RAP
73
003-973 Image Rotation RAP
74
003-974 Next Original Specification RAP
74
003-976 FAX Line Memory Overflow RAP
75
003-977 Document Mismatch (Multiple Scan) RAP
75
003-978 Color Document Miss Match (Multi Scan) RAP
76
003-980 Staple Position RAP
76
003-981 Staple Size RAP
77
Chain 005
78
005-110 Belt DADF Regi Sensor On Dynamic Jam RAP
78
005-111 Belt DADF Regi Sensor Off Dynamic Jam RAP
78
005-112 Belt DADF Regi Sensor On Dynamic Jam RAP (Document Reverse)
79
005-113 Belt DADF Regi Sensor Off Dynamic Jam RAP (Document Reverse)
79
005-115 Belt DADF Exit Sensor On Dynamic Jam
80
005-116 Belt DADF Exit Sensor Off Dynamic Jam
80
005-121 CVT Feed Sensor On Jam RAP
81
005-122 CVT Simplex/Side1 Pre-Registration On Jam RAP
82
005-123 CVT Simplex/Side1 Registration Jam RAP
83
005-124 CVT Lead Reg Sensor On Jam
84
005-125 CVT Registration Sensor Off Jam RAP
84
005-126 CVT Out Sensor On Jam
85
005-127 CVT Out Sensor Off Jam
86
005-128 CVT Simplex Exit 1 Sensor On Jam
86
005-129 CVT Simplex Exit 1 Sensor Off Jam
87
005-130 CVT Invert Sensor On Jam
87
005-131 CVT Invert On Jam RAP
88
005-132 CVT Invert On Jam 2 RAP
89
005-133 CVT Invert Sensor Off Jam
90
005-134 CVT Invert Sensor Off Jam (Inverter) RAP
90
005-135 CVT Side2 Pre-Registration On Jam RAP
91
005-136 CVT Side2 Registration On Jam RAP
92
005-137 CVT Exit 2 Sensor On Jam
93
005-138 CVT Exit 1 Sensor On Jam (Side 2)
94
005-139 CVT Invert Sensor Off Jam RAP
94
005-141 CVT Feed Sensor Off Jam
95
005-142 CVT Exit 1 Sensor Off Jam (Side 2)
96
005-143 CVT Exit 2 Sensor Off Jam
96
005-144 CVT Pre Reg Sensor Jam
97
005-145 CVT Registration Sensor Off Jam (Invert) RAP
97
005-146 CVT Pre Registration Sensor Off Jam RAP
98
005-147 CVT Pre Registration Sensor Off Jam (Invert) RAP
99
005-150 CVT Holed Paper Feed Sensor Off Jam
100
005-151 CVT Holed Paper Pre Reg Sensor Off Jam
101
005-152 CVT Holed Paper Reg Sensor Off Jam
101
005-153 CVT Holed Paper Pre Reg Sensor Off Jam
102
005-154 CVT Holed Paper Out Sensor Off Jam
102
005-155 CVT Holed Paper Simplex Exit 1 Sensor Off Jam
103
005-156 CVT Holed Paper Duplex Exit 1 Sensor Off Jam
103
005-157 CVT Holed Paper Invert Sensor Off Jam
104
005-158 CVT Holed Paper Exit 2 Sensor Off Jam
104
005-160 DADF Tray Lift Up Fail on running (Document Set)
105
005-190 Feed Motor Logic Error Jam
105
005-194 Mixed Size Mismatch RAP
106
005-195 Size Mismatch Jam
107
005-196 CVT Size Mismatch RAP
107
005-197 Prohibit Combine Size RAP
108
005-198 Document Length RAP
109
005-210 DADF Download Fail
111
005-274 Original Size Sensor Fail
112
005-275 DADF RAM Failure RAP
112
005-280 DADF EEPROM RAP
113
005-281 DADF Tray Lift Down Failure
113
005-282 DADF Tray Lift Up Failure
114
005-283 DADF Nudger Sensor RAP
114
005-284 DADF APS Sensor Logic RAP
115
005-285 DADF Nudger Lift Up RAP
116
005-286 DADF Feed Out Sensor RAP
117
005-301 DADF Top Cover Open
118
005-302 CVT Feeder Cover Interlock Open RAP
119
005-304 CVT Platen Interlock Open RAP
119
005-305 CVT Feeder Cover Interlock Open (running) RAP
120
005-306 Tray Interlock Open while Running
120
005-307 CVT Platen Interlock Open on Running RAP
121
005-906 CVT Feed Sensor RAP
121
005-907 CVT Pre-Registration Sensor RAP
122
005-309 Left Hand Interlock Open while Running
123
005-900 No Belt DADF Applicable Sensor Static Jam
123
005-901 Belt DADF Doc Sensor Static Jam
124
005-902 Belt DADF Regi Sensor Static Jam
124
005-903 Belt DADF Exit Sensor Static Jam
125
005-904 Belt Dup Sensor Static Jam
125
005-909 DADF Lead Sensor Static Jam
126
005-911 DADF Exit 1 Sensor Static Jam
127
005-912 DADF Exit 2 Sensor Static Jam
127
005-913 CVT Invert Sensor RAP
128
005-914 DADF APS1, 2, 3, Sensor Static Jam
128
005-915 CVT APS No1 Sensor RAP
129
005-916 CVT APS No2 Sensor RAP
129
005-917 CVT APS No3 Sensor RAP
130
005-918 CVT Invert Sensor Static Jam
130
005-919 DADF Tray Lift Up Failure not during Job
131
005-941 DADF Not Enough Documents Failure
132
005-942 Document Loading RAP
132
005-943 DADF Tray Lift Up RAP
133
Chain 010
136
010-311 Fuser Rear Thermistor Disconnected RAP
136
010-313 Control (Center) Thermistor RAP
137
010-314 Rear Thermistor RAP
137
010-318 Hot-Sagging Recovery RAP
138
010-319 Fuser Center Thermistor Differential Amp RAP
138
010-320 Heat Roll Over Temperature RAP
139
010-327 Fuser On Time RAP
140
010-328 Fuser Warm-up Time RAP
141
010-330 Fuser Motor Failure RAP
142
010-331 Fuser Rear Thermistor Over Temp RAP
142
010-332 Fuser Center Thermistor Disconnected RAP
143
010-333 Fuser Center Thermistor Overtemp RAP
144
010-334 Fuser Center Thermistor Broken RAP
145
010-335 Fuser Center Thermistor Out of Range RAP
146
010-336 Sub Lamp Disconnection Failure RAP
147
010-398 Fuser Lock RAP
148
010-420 Fuser Near end of life RAP
149
010-421 Fuser end of life RAP
149
Chain 012
150
012-111 Finisher H-Transport Entrance Sensor Off Jam RAP
150
012-112 Finisher H-Transport Entrance Sensor On Jam RAP
151
012-121 H-Transport Exit Sensor Off Jam RAP
152
012-126 H-Transport Entrance Sensor OFF Jam B RAP
153
012-151 Compile Entrance Sensor Off Jam RAP
154
012-152 Compile Entrance Sensor On Jam RAP
155
012-161 Finisher Set Eject Jam RAP
156
012-162 H-Tra EXIT Sensor On Jam RAP
157
012-211 Stacker Tray RAP
158
012-212 Stacker Tray Upper Limit RAP
159
012-221 Front Tamper Home Sensor On RAP
160
012-223 Front Tamper Home Sensor Off RAP
161
012-224 Rear Tamper Home Sensor Off RAP
162
012-260 Eject Clamp Home Sensor ON RAP
163
012-263 Rear Tamper Home Sensor ON RAP
164
012-282 Eject Clamp Home Sensor Off RAP
165
012-283 Set Clamp Home Sensor On RAP
166
012-284 Set Clamp Home Sensor Off RAP
167
012-285 Finisher Error
168
012-291 Stapler RAP
168
012-293 Staple Front Corner Sensor On RAP
169
012-294 Staple Front Corner Sensor Off RAP
170
012-295 Staple Move Sensor On RAP
171
012-296 Staple Move Sensor Off RAP
172
012-301 Finisher Top Cover Open RAP
173
012-302 Finisher Front Cover Open RAP
174
012-303 Finisher H-Transport Cover Open RAP
174
012-310 Front Tamper Home Sensor On Fail RAP
175
012-311 Front Tamper Home Sensor Off Fail RAP
176
012-312 Rear Tamper Home Sensor ON Fail RAP
177
012-313 Rear Tamper Home Sensor Off Fail RAP
178
012-314 Eject Clamp Home Sensor On Failure RAP
179
012-315 Eject Clamp Home Sensor Off Failure RAP
180
012-316 Stapler Failure RAP
181
012-317 Stapler Feed Ready Failure RAP
182
012-318 Set Clamp Home Sensor On Failure RAP
182
012-319 Set Clamp Home Sensor Off Failure RAP
183
012-350 Finisher Communications Failure RAP
184
012-500
185
012-600 Staple Mode Logic
186
012-901 Finisher H-Transport Entrance Sensor RAP
186
012-902 H-Transport Exit Sensor RAP
187
012-903 Paper Remains at Compiler Entrance Sensor RAP
187
012-905 Compile Paper Sensor RAP
188
012-923 H-Transport Entrance Sensor B RAP
188
012-132 (A-Finisher) Ent Sensor ON Jam
190
012-151 (A-Finisher) Compiler Exit Sensor OFF Jam
191
012-152 (A-Finisher) Compiler Exit Sensor ON Jam
192
012-161 (A-Finisher) Set Eject Jam
193
012-211 (A-Finisher) Stacker Tray Fail
194
012-221 (A-Finisher) Front Tamper Home Sensor ON Fail
196
012-223 (A-Finisher) Front Tamper Home Sensor OFF Fail
197
012-224 (A-Finisher) Rear Tamper Home Sensor OFF Fail
198
012-259 (A-Finisher) Eject Home Sensor ON Fail
199
012-263 (A-Finisher) Rear Tamper Home Sensor ON Fail
200
012-280 (A-Finisher) Eject Home Sensor OFF Fail
201
012-283 (A-Finisher) Set Clamp Home Sensor ON Fail
202
012-284 (A-Finisher) Set Clamp Home Sensor OFF Fail
203
012-291 (A-Finisher) Stapler Fail
204
012-301 (A-Finisher) Top Cover Interlock OPEN
205
012-302 (A-Finisher) Front Cover Interlock OPEN
206
012-903 (A-Finisher) Paper Remains at Compiler Exit Sensor
206
012-935 (A-Finisher) Paper Remains at Ent Sensor
207
Chain 016
208
016-211 Software Option (System Memory Low) RAP
208
016-212 Software Option (Page Memory Low) RAP
209
016-213 Software Option (Printer PWB) RAP
209
016-214 Serial Number Mismatch RAP
210
016-215 Software Option RAP
210
016-216 Software Option RAP
211
016-217 Software Option RAP
211
016-219 Software Option RAP
212
016-311 Scanner Install RAP
212
016-315 IIT Interface RAP
213
016-316 Page Memory Not Detected RAP
213
016-317 Page Memory Error- Standard RAP
214
016-318 Page Memory Error- Option RAP
214
016-321 Fax Module RAP
215
016-322 JBA Account Full RAP
215
016-323 B Formatter RAP
216
016-450 SMB Host Name Duplicated RAP
216
016-454 DNS Dynamic Update RAP
217
016-455 SMTP Server Time-out RAP
217
016-456 SMTP time asynchronous RAP
218
016-461 TBD RAP
218
016-500 DIMM RAP
219
016-501 S2X RAP
219
016-502 ROM Write RAP
220
016-503 SMTP Redirector RAP
220
016-504 Redirector POP Server RAP
221
016-505 Redirector POP Authentication RAP
221
016-506 Image Log RAP
222
016-507 Image Log Send RAP
222
016-508 Image Log RAP
223
016-509 Image Log RAP
223
016-510 Image Log RAP
224
016-511 Image Log RAP
224
016-512 Image Log RAP
225
016-522 LDAP RAP
225
016-523 LDAP RAP
226
016-524 LDAP RAP
226
016-525 LDAP RAP
227
016-526 LDAP RAP
227
016-527 LDAP RAP
228
016-533 LDAP RAP
228
016-534 LDAP RAP
229
016-539 LDAP RAP
229
016-539 LDAP RAP
230
016-543 Attestation Agent error 543 (REALM_UNKNOWN) RAP
230
016-545 Attestation Agent error 545 (CLOCKSKEW_ERR) RAP
231
016-546 Attestation Agent error 546 RAP
231
016-548 Attestation Agent error 548 (UNREGISTERED_DEVICE) RAP
232
016-553 Attestation Agent error 553 (VERSION_MISMATCH) RAP
232
016-554 Attestation Agent error 554 (CONFIGRATION_ERROR) RAP
233
016-555 Attestation Agent error 555 (SERVICE_ISNOT_WORKING) RAP
233
016-556 Attestation Agent error 556 (SERVICE_IS_PROCESSING) RAP
234
016-557 Attestation Agent error 557 (INTERNAL_ERROR) RAP
234
016-558 Attestation Agent error 558 (MISC_ERR) RAP
235
016-560 Attestation Agent error 560 RAP
235
016-562 Attestation Agent error 562 RAP
236
016-569 Attestation Agent error 569 RAP
236
016-574 Host Name Error RAP
237
016-575 DNS Server Error in FTP RAP
237
016-576 Server Connection Error in FTP RAP
238
016-577 FTP Service RAP
238
016-578 Login/Password Error RAP
239
016-579 Scanning Picture Error RAP
239
016-580 File Name Acquisition Failure RAP
240
016-581 File Name Suffix Limit Error RAP
240
016-582 File Creation Failure RAP
241
016-583 Lock Folder Creation Failure RAP
241
016-584 Folder Creation Failure RAP
242
016-585 File Delete Failure RAP
242
016-586 Lock Folder Delete Failure RAP
243
016-587 Folder Delete Failure RAP
243
016-588 Data Write-in Failure RAP
244
016-589 Data Read Failure RAP
244
016-590 Data Reading Failure RAP
245
016-591 Scan Filing Policy Injustice RAP
245
016-592 NEXTNAME.DAT file access error RAP
246
016-593 Internal Scan Error RAP
246
016-594 TYPE Command Failure RAP
247
016-595 Port Command Failure RAP
247
016-597 Same Name File Exists RAP
248
016-600 Key Operator Authentication Locked RAP
249
016-701 ART EX Memory Expended RAP
250
016-702 Out of Page Buffer RAP
250
016-703 E-mail To Invalid Box RAP
251
016-704 Mailbox Full RAP
251
016-705 Secure Print RAP
252
016-706 Maximum Users Exceeded RAP
252
016-707 Sample Print RAP
253
016-708 HDD Full Annotation/Watermark RAP
253
016-709 ART EX Command RAP
254
016-710 Delayed Print RAP
254
016-711 E-mail Transmission Size Limit RAP
255
016-712 Panther Capacity (I-Formatted) RAP
255
016-713 Security Box Password RAP
256
016-714 Security Box Enable RAP
256
016-716 TIFF Data Overflow RAP
257
016-717 Fax/iFax Send RAP
257
016-718 PCL6 Memory RAP
258
016-719 Out of PCL Memory RAP
258
016-720 PCL Command RAP
259
016-721 Other Errors RAP
259
016-722 Staple Position RAP
260
016-724 Staple Position RAP
260
016-725 B-Formatter Image RAP
261
016-726 PDL Auto Switch RAP
261
016-727 Printer Request
262
016-728 TIFF Data Unsupported RAP
262
016-729 TIFF Data Size RAP
263
016-730 ART Command Unsupported RAP
263
016-731 TIFF Data Invalid RAP
264
016-732 Form Not Registered RAP
264
016-733 Destination Address RAP
265
016-734 Transmission Report RAP
265
016-735 Updating Job Template RAP
266
016-736 Remote Directory Lock RAP
266
016-737 Remote Directory Removal RAP
267
016-741 Downloading Mode RAP
267
016-742 TBD RAP
268
016-743 TBD RAP
268
016-744 TBD RAP
269
016-745 TBD RAP
269
016-746 Unsupported PDF File RAP
270
016-747 Insufficient Memory
270
016-749 Post Script Font RAP
271
016-750 Print Job RAP
272
016-752 PDF Memory Limit RAP
273
016-753 PDF Password Mismatch RAP
273
016-754 PDF LZW Not Installed RAP
274
016-755 PDF Print Prohibited RAP
274
016-756 Auditron - Prohibit Service RAP
275
016-757 Auditron - Invalid User RAP
275
016-758 Auditron - Disabled Function RAP
276
016-759 Auditron - Reached Limit RAP
276
016-760 PostScript Decompose RAP
277
016-761 FIFO Empty RAP
277
016-762 Print Language RAP
278
016-764 SMTP Server Connection RAP
278
016-765 SMTP Server HDD Full RAP
279
016-766 SMTP Server File System RAP
279
016-767 Invalid E-mail Address RAP
280
016-768 Invalid Sender Address RAP
280
016-769 SMTP Server Unsupported DSN RAP
281
016-770 FAX Function Cancelled RAP
281
016-771 JBIG Parameter RAP
282
016-772 JBIG Parameter RAP
282
016-773 JBIG Parameter RAP
283
016-774 JBIG Parameter RAP
283
016-775 JBIG Parameter RAP
284
016-776 JBIG Parameter RAP
284
016-777 JBIG Parameter RAP
285
016-778 JBIG Parameter RAP
285
016-779 Scanned Image Conversion Error RAP
286
016-780 Attached Document TIFF RAP
286
016-781 Scan Server Connect Error RAP
287
016-782 Scan Server Login Error RAP
289
016-784 Server Write Error RAP
291
016-785 Server HD Full RAP
291
016-786 HD Full-Scan Write Error RAP
292
016-787 Invalid Server IP ADD RAP
292
016-788 Retrieve to Browser RAP
293
016-789 HD Full - Job Memory RAP
293
016-790 Stapling Cancelled RAP
294
016-791 File Retrieve RAP
294
016-792 Specified Job RAP
295
016-793 MF I/O HD Full RAP
295
016-798 No Trust Marking Option RAP
296
016-799 PLW Print Instruction RAP
296
016-981 HDD access error RAP
297
016-982 HDD access error 2 RAP
297
016-983 Log Image Storage Area on Disk Full RAP
298
016-985 Data size overflow (Scan to E-mail) RAP
298
Chain 018
300
018-505 SMB-DOS protocol error RAP
300
018-543 Shared name error in SMB server RAP
300
018-547 Number restriction over of SMB scan users RAP
301
018-595 LDAP protocol error RAP
301
018-701 LDAP RAP
302
018-702 LDAP RAP
302
018-703 LDAP RAP
303
018-704 LDAP RAP
303
018-705 LDAP RAP
304
018-706 LDAP RAP
304
018-707 LDAP RAP
305
018-708 LDAP RAP
305
018-710 LDAP RAP
306
018-711 LDAP RAP
306
018-712 LDAP RAP
307
018-713 LDAP RAP
307
018-714 LDAP RAP
308
018-716 LDAP RAP
308
018-717 LDAP RAP
309
018-718 LDAP RAP
309
018-719 LDAP RAP
310
018-720 LDAP RAP
310
018-721 LDAP RAP
311
018-732 LDAP RAP
311
018-733 LDAP RAP
312
018-734 LDAP RAP
312
018-735 LDAP RAP
313
018-736 LDAP RAP
313
018-748 LDAP RAP
314
018-749 LDAP RAP
314
018-750 LDAP RAP
315
018-751 LDAP RAP
315
018-752 LDAP RAP
316
018-753 LDAP RAP
316
018-754 LDAP RAP
317
018-764 LDAP RAP
317
018-765 LDAP RAP
318
018-766 LDAP RAP
318
018-767 LDAP RAP
319
018-768 LDAP RAP
319
018-769 LDAP RAP
320
018-770 LDAP RAP
320
018-771 LDAP RAP
321
018-780 LDAP RAP
321
018-781 LDAP RAP
322
018-782 LDAP RAP
322
018-783 LDAP RAP
323
018-784 LDAP RAP
323
018-785 LDAP RAP
324
018-786 LDAP RAP
324
018-787 LDAP RAP
325
018-788 LDAP RAP
325
018-789 LDAP RAP
326
018-790 LDAP RAP
326
018-791 LDAP RAP
327
018-792 LDAP RAP
327
018-793 LDAP RAP
328
018-794 LDAP RAP
328
018-795 LDAP RAP
329
018-796 LDAP RAP
329
018-797 LDAP RAP
330
Chain 021
332
021-360 EP Accessory Failure RAP
332
021-361 EP Accessory Kind Configuration Error RAP
332
021-731 EP Accessory - Function Disabled RAP
333
021-732 EP Accessory - Service Canceled By Disable RAP
333
021-733 EP Accessory - Service Canceled By Color Mode Restriction RAP
334
021-750 Used Parts Request Failure (EP-SV) RAP
334
021-751 Maintenance Request Failure (EP-SV) RAP
335
021-770 Used Parts Request Failure (EP-DX) RAP
335
021-771 Maintenance Request Failure (EP-DX) RAP
336
021-772 EP-DX - Installation/Removal Failure RAP
336
021-941 EP - Scan Service Paused By Disable RAP
337
021-942 EP - Scan Service Paused By Color Mode RAP
337
021-943 EP - Print Service Paused By Disable RAP
338
021-944 EP - Print Service Paused By Color Mode RAP
338
021-945 EP - Service Paused By Disable RAP
339
021-946 EP - Service Paused By Color Mode RAP
339
Chain 024
340
024-340 IOT-ESS Communication 1 RAP
340
024-341 IOT-ESS Communication 2 RAP
340
024-342 IOT-ESS Communication 3 RAP
341
024-343 IOT-ESS Communication 4 RAP
341
024-345 IOT-ESS Communication 5 RAP
342
024-346 IOT-ESS Communication 6 RAP
342
024-347 IOT-ESS Communication 7 RAP
343
024-348 IOT-ESS Communication 8 RAP
343
024-349 IOT-ESS Communication 9 RAP
344
024-350 IOT-ESS Communication 10 RAP
344
024-351 IOT-ESS Communication 11 RAP
345
024-354 IOT-ESS Communication 14 RAP
345
024-356 IOT-ESS Communication 16 RAP
346
024-360 IOT-ESS Initialization RAP
346
024-362 Page Sync Start RAP
347
024-363 Page Sync Stop RAP
347
024-364 DMA Transfer RAP
348
024-367 Decompression Synchronization RAP
348
024-368 PCI RAP
349
024-370 Marker Code Detection RAP
349
024-371 IOT-ESS Communication 21 RAP
350
024-372 IOT-ESS Communication 22 RAP
350
024-373 IOT-ESS Communication 23 RAP
351
024-375 IOT-ESS Communication 24 RAP
351
024-600 Billing Master Counter RAP
352
024-601 Billing Backup Counter 1 RAP
352
024-602 Billing Backup Counter 2 RAP
353
024-603 Software Key Master Counter RAP
353
024-604 Software Key Backup Counter 1 RAP
354
024-605 Software Key Backup Counter 2 RAP
354
024-747 Print Instruction RAP
355
024-910 Tray 1 size mismatch RAP
356
024-911 Tray 2 size mismatch RAP
357
024-912 Tray 3 size mismatch RAP
358
024-916 Mix Full Stack RAP
359
024-917 Stacker Tray Staple Set Over Count RAP
360
024-919 Face UP Tray Close RAP
360
024-920 Face Down Tray 1 Paper Full RAP
361
024-922 Face Down Tray 1 Paper Full RAP
361
024-923 Y Toner Empty
362
024-924 M Toner Empty
362
024-925 C Toner Empty
363
024-928 Scratch Sheet Compile RAP
363
024-930 Stacker Tray Full RAP
364
024-934 Paper Type Mismatch RAP
365
024-946 Tray 1 Position RAP
365
024-947 2TM Tray 2 Position RAP
366
024-947 TTM Tray 2 Position RAP
366
024-948 2TM Tray 3 Position RAP
367
024-948 TTM Tray 3 Position RAP
367
024-950 Tray 1 Empty RAP
368
024-951 2TM Tray 2 Empty RAP
368
024-951 TTM Tray 2 Empty RAP
369
024-952 2TM Tray 3 Empty RAP
369
024-952 TTM Tray 3 Empty RAP
370
024-954 MSI Empty RAP
370
024-958 MSI Size RAP
371
024-959 Tray 1 Paper Size RAP
372
024-960 Tray 2 Paper Size RAP
373
024-961 Tray 3 Paper Size RAP
374
024-965 ATS/APS Paper (IOT detect) RAP
375
024-966 ATS/APS Destination RAP
376
024-967 Mixed Width Paper (Staple Job) RAP
377
024-976 Staple Status Failed RAP
378
024-977 Stapler Feed Ready RAP
379
024-979 Stapler Near Empty RAP
379
024-980 Stacker Tray Full RAP
380
024-982 Stacker Lower Safety Warning RAP
381
024-985 MSI Feed RAP
382
024-916 (A-Finisher) Mix Stack Full
384
024-917 (A-Finisher) Stacker Tray Staple Set Over Count
385
024-928 (A-Finisher) Scratch Sheet Compile
387
024-930 (A-Finisher) Stacker Tray Full Stack
387
024-976 (A-Finisher) Staple NG
389
024-977 (A-Finisher) Stapler Feed Ready Fail
390
024-979 (A-Finisher) Stapler Near Empty
390
024-980 (A-Finisher) Stacker Tray Full Stack
391
024-982 (A-Finisher) Stacker Lower Safety Warning
392
Chain 025
394
025-596 Diagnostic HDD Maintenance RAP
394
025-597 Diagnostic HDD Initialize RAP
394
Chain 026
396
026-700 LDAP Protocol Max Error RAP
396
026-701 Address Book Request Overflow RAP
396
026-702 Address Book Directory Service Overflow RAP
397
Chain 027
398
027-452 Duplicate IP Address RAP
398
027-500 SMTP Server Mail I/O RAP
398
027-501 POP Server RAP
399
027-502 POP Authentication RAP
399
027-513 SMB Scan Client RAP
400
027-514 Host Name Solution Error RAP
400
027-515 DNS Server Error in SMB RAP
401
027-516 Server Connection Error in SMB RAP
401
027-518 Login/Password Error RAP
402
027-519 Scanning Picture Error RAP
402
027-520 File Name Acquisition Failure RAP
403
027-521 File Name Suffix Limit Error RAP
403
027-522 File Creation Failure RAP
404
027-523 Lock Folder Creation Failure RAP
404
027-524 Folder Creation Failure RAP
405
027-525 File Delete Failure RAP
405
027-526 Lock Folder Delete Failure RAP
406
027-527 Folder Delete Failure RAP
406
027-528 Data Write-in Failure RAP
407
027-529 Data Read Failure RAP
407
027-530 Data Reading Failure RAP
408
027-531 Scan Filing Policy Injustice RAP
408
027-532 NEXTNAME.DAT file access error RAP
409
027-533 Internal Scan Error RAP
409
027-543 Server Name Specification Error RAP
410
027-547 SMB Protocol error 4-007 RAP
410
027-548 SMB Protocol error 4-008 RAP
411
027-549 SMB Protocol error 4-009 RAP
411
027-564 SMB Protocol error 4-024 RAP
412
027-565 SMB Protocol error 4-025 RAP
412
027-566 SMB Protocol error 4-026 RAP
413
027-569 SMB (TCP/IP) is not Started RAP
413
027-572 SMB Protocol error 4-032 RAP
414
027-573 SMB Protocol error 4-033 RAP
414
027-574 SMB Protocol error 4-034 RAP
415
027-576 SMB Protocol error 4-036 RAP
415
027-578 SMB Protocol error 4-038 RAP
416
027-584 SMB Protocol error 4-044 RAP
416
027-585 SMB Protocol error 4-045 RAP
417
027-586 SMB Protocol error 4-046 RAP
417
027-587 SMB Protocol error 4-047 RAP
418
027-588 SMB Protocol error 4-048 RAP
418
027-589 SMB Protocol error 4-049 RAP
419
027-590 SMB Protocol error 4-050 RAP
419
027-591 SMB Protocol error 4-051 RAP
420
027-599 SMB Protocol error 4-other codes RAP
420
027-599 SMB Protocol error 4-other codes RAP
421
027-706 Certificate RAP
421
027-707 Certificate Expired RAP
422
027-708 Certificate Valid RAP
422
027-709 Certificate Revoked RAP
423
027-710 Invalid S/MIME Mail RAP
423
027-711 S/MIME Mail Certificate RAP
424
027-712 S/MIME Mail Certificate RAP
424
027-713 S/MIME Mail Altered RAP
425
027-714 S/MIME Mail Invalid RAP
425
027-715 S/MIME Mail Certificate Registration RAP
426
027-716 Email Signature RAP
426
027-720 Extension Server Host RAP
427
027-721 Extension Server RAP
427
027-722 Extension Server Time-out RAP
428
027-723 Extension Server Authentication RAP
428
027-724 Extension Server Access RAP
429
027-725 Extension Server Operation RAP
429
027-726 Extension Server State RAP
430
027-727 Extension Server Parameters RAP
430
027-728 Extension Server File RAP
431
027-737 Template Server Read RAP
431
027-739 Invalid Template Server Path RAP
432
027-740 Template Server Login RAP
432
027-741 Template Server Connect RAP
433
027-742 HDD File System RAP
433
027-743 Template Server Install RAP
434
027-744 Template Address RAP
434
027-745 Template Address Server RAP
435
027-746 Job Template Pool Server RAP
435
027-750 Fax Document Inhibited RAP
436
027-751 Job Template Analysis RAP
436
027-752 Required User Entry Not Entered RAP
437
027-753 Job Flow Service Disabled RAP
437
027-754 Job Flow Service File Signature Mismatch RAP
438
027-796 E-mail Not Printed RAP
438
027-797 Invalid Output Destination RAP
439
Chain 033
440
033-363 Fax Control RAP
440
033-710 Fax Control RAP
440
033-712 Fax Control RAP
441
033-713 Fax Control RAP
441
033-715 Fax Control RAP
442
033-716 Fax Control RAP
442
033-717 Fax Control RAP
443
033-718 Fax Control RAP
443
033-719 Fax Control RAP
444
033-721 Fax Control RAP
444
033-722 Fax Control RAP
445
033-724 Fax Control RAP
445
033-725 Fax Control RAP
446
033-726 Fax Control RAP
446
033-727 Fax Control RAP
447
033-728 Fax Control RAP
447
033-731 Fax Control RAP
448
033-732 Fax Control RAP
448
033-733 Fax Control RAP
449
033-734 Fax Control RAP
449
033-735 Fax Control RAP
450
033-736 Fax Control RAP
450
033-737 Fax Control RAP
451
033-738 Fax Control RAP
451
033-740 Fax Control RAP
452
033-741 Fax Control RAP
452
033-742 Fax Control RAP
453
033-743 Fax Control RAP
453
033-744 Fax Control RAP
454
033-745 Fax Control RAP
454
033-746 Fax Control RAP
455
033-747 Fax Control RAP
455
033-749 Fax Control RAP
456
033-750 Fax Control RAP
456
033-751 Activity Report suspended RAP
457
033-755 Fax printing is canceled Fax RAP
457
033-790 Fax Control RAP
458
033-755 Fax Control RAP
458
033-792 Fax Control RAP
459
Chain 034
460
034-211 Fax Communication RAP
460
034-212 Fax Communication RAP
460
034-500 Fax Communication RAP
461
034-501 Fax Communication RAP
461
034-505 Fax Communication RAP
462
034-506 Fax Communication RAP
462
034-507 Fax Communication RAP
463
034-508 Fax Communication RAP
463
034-509 Fax Communication RAP
464
034-510 Fax Communication RAP
464
034-511 Fax Communication RAP
465
034-512 Fax Communication RAP
465
034-513 Fax Communication RAP
466
034-514 Fax Communication RAP
466
034-515 Fax Communication RAP
467
034-519 Fax Communication RAP
467
034-520 Fax Communication RAP
468
034-522 Fax Communication RAP
468
034-523 Fax Communication RAP
469
034-528 Fax Communication RAP
469
034-529 Fax Communication RAP
470
034-530 Fax Communication RAP
470
034-550 Write to FaxCard-ROM error detection RAP
471
034-702 Fax Communication RAP
471
034-703 Fax Communication RAP
472
034-704 Fax Communication RAP
472
034-705 Fax Communication RAP
473
034-706 Fax Communication RAP
473
034-707 Fax Communication RAP
474
034-708 Fax Communication RAP
474
034-709 Fax Communication RAP
475
034-710 Fax Communication RAP
475
034-711 Fax Communication RAP
476
034-712 Fax Communication RAP
476
034-713 Fax Communication RAP
477
034-714 Fax Communication RAP
477
034-715 Fax Communication RAP
478
034-716 Fax Communication RAP
478
034-717 Fax Communication RAP
479
034-718 Fax Communication RAP
479
034-719 Fax Communication RAP
480
034-720 Fax Communication RAP
480
034-722 Fax Communication RAP
481
034-724 Fax Communication RAP
481
034-725 Fax Communication RAP
482
034-726 Fax Communication RAP
482
034-729 Fax Communication RAP
483
034-730 Fax Communication RAP
483
034-731 Fax Communication RAP
484
034-732 Fax Communication RAP
484
034-733 Fax Communication RAP
485
034-735 Fax Communication RAP
485
034-736 Fax Communication RAP
486
034-737 Fax Communication RAP
486
034-738 Fax Communication RAP
487
034-739 Fax Communication RAP
487
034-740 Fax Communication RAP
488
034-741 Fax Communication RAP
488
034-742 Fax Communication RAP
489
034-743 Fax Communication RAP
489
034-744 Fax Communication RAP
490
034-745 Fax Communication RAP
490
034-746 Fax Communication RAP
491
034-747 Fax Communication RAP
491
034-748 Fax Communication RAP
492
034-749 Fax Communication RAP
492
034-750 Fax Communication RAP
493
034-751 Fax Communication RAP
493
034-752 Fax Communication RAP
494
034-753 Fax Communication RAP
494
034-754 Fax Communication RAP
495
034-755 Fax Communication RAP
495
034-756 Fax Communication RAP
496
034-757 Fax Communication RAP
496
034-758 Fax Communication RAP
497
034-759 Fax Communication RAP
497
034-760 Fax Communication RAP
498
034-761 Fax Communication RAP
498
034-762 Fax Communication RAP
499
034-763 Fax Communication RAP
499
034-764 Fax Communication RAP
500
034-765 Fax Communication RAP
500
034-766 Fax Communication RAP
501
034-767 Fax Communication RAP
501
034-768 Fax Communication RAP
502
034-769 Fax Communication RAP
502
034-770 Fax Communication RAP
503
034-771 Fax Communication RAP
503
034-772 Fax Communication RAP
504
034-773 Fax Communication RAP
504
034-774 Fax Communication RAP
505
034-775 Fax Communication RAP
505
034-776 Fax Communication RAP
506
034-777 Fax Communication RAP
506
034-778 Fax Communication RAP
507
034-779 Fax Communication RAP
507
034-780 Fax Communication RAP
508
034-781 Fax Communication RAP
508
034-782 Fax Communication RAP
509
034-783 Fax Communication RAP
509
034-784 Fax Communication RAP
510
034-785 Fax Communication RAP
510
034-786 Fax Communication RAP
511
034-787 Fax Communication RAP
511
034-788 Fax Communication RAP
512
034-789 Fax Communication RAP
512
034-790 Fax Communication Channel 0 RAP
513
034-791 Fax Communication Channel 1 RAP
513
034-792 Fax Communication Channel 2 RAP
514
034-793 Fax Communication Channel 3 RAP
514
034-794 Fax Communication Channel 4 RAP
515
034-795 Fax Communication Channel 5 RAP
515
034-796 Fax Communication Channel RAP
516
Chain 035
518
035-500 Fax Protocol RAP
518
035-550 Write to FaxG3-ROM error detection RAP
518
035-700 Fax Protocol RAP
519
035-701 Fax Protocol RAP
519
035-702 Fax Protocol RAP
520
035-703 Fax Protocol RAP
520
035-704 Fax Protocol RAP
521
035-705 Fax Protocol RAP
521
035-706 Fax Protocol RAP
522
035-707 Fax Protocol RAP
522
035-708 Fax Protocol RAP
523
035-709 Fax Protocol RAP
523
035-710 Fax Protocol RAP
524
035-711 Fax Protocol RAP
524
035-712 Fax Protocol RAP
525
035-713 Fax Protocol RAP
525
035-714 Fax Protocol RAP
526
035-715 Fax Protocol RAP
526
035-716 Fax Protocol RAP
527
035-717 Fax Protocol RAP
527
035-718 Fax Protocol RAP
528
035-719 Fax Protocol RAP
528
035-720 Fax Protocol RAP
529
035-721 Fax Protocol RAP
529
035-722 Fax Protocol RAP
530
035-723 Fax Protocol RAP
530
035-724 Fax Protocol RAP
531
035-725 Fax Protocol RAP
531
035-726 Fax Protocol RAP
532
035-727 Fax Protocol RAP
532
035-728 Fax Protocol RAP
533
035-729 Fax Protocol RAP
533
035-730 Fax Protocol RAP
534
035-731 Fax Protocol RAP
534
035-732 Fax Protocol RAP
535
035-733 Fax Protocol RAP
535
035-734 Fax Protocol RAP
536
035-735 Fax Protocol RAP
536
035-736 Fax Protocol RAP
537
035-737 Fax Protocol RAP
537
035-738 Fax Protocol RAP
538
035-739 Fax Protocol RAP
538
035-740 Fax Protocol RAP
539
035-741 Fax Protocol RAP
539
035-742 Fax Protocol RAP
540
035-743 Fax Protocol RAP
540
035-744 Fax Protocol RAP
541
035-745 Fax Protocol RAP
541
035-746 Fax Protocol RAP
542
035-747 Fax Protocol RAP
542
035-748 Fax Protocol RAP
543
035-749 Fax Protocol RAP
543
035-750 Fax Protocol RAP
544
035-751 Fax Protocol RAP
544
035-752 Fax Protocol RAP
545
035-762 Fax Protocol RAP
545
Chain 036
546
036-500 Fax Parameter RAP
546
036-501 Fax Parameter RAP
546
036-502 Fax Parameter RAP
547
036-503 Fax Parameter RAP
547
036-504 Fax Parameter RAP
548
036-505 Fax Parameter RAP
548
036-506 Fax Parameter RAP
549
036-507 Fax Parameter RAP
549
036-508 Fax Parameter RAP
550
036-509 Fax Parameter RAP
550
036-510 Fax Parameter RAP
551
036-511 Fax Parameter RAP
551
036-512 Fax Parameter RAP
552
036-513 Fax Parameter RAP
552
036-514 Fax Parameter RAP
553
036-515 Fax Parameter RAP
553
036-516 Fax Parameter RAP
554
036-517 Fax Parameter RAP
554
036-518 Fax Parameter RAP
555
036-519 Fax Parameter RAP
555
036-520 Fax Parameter RAP
556
036-521 Fax Parameter RAP
556
036-522 Fax Parameter RAP
557
036-523 Fax Parameter RAP
557
036-524 Fax Parameter RAP
558
036-525 Fax Parameter RAP
558
036-526 Fax Parameter RAP
559
036-527 Fax Parameter RAP
559
036-528 Fax Parameter RAP
560
036-529 Fax Parameter RAP
560
036-530 Fax Parameter RAP
561
036-531 Fax Parameter RAP
561
036-532 Fax Parameter RAP
562
036-533 Fax Parameter RAP
562
036-534 Fax Parameter RAP
563
036-535 Fax Parameter RAP
563
036-536 Fax Parameter RAP
564
036-537 Fax Parameter RAP
564
036-538 Fax Parameter RAP
565
036-539 Fax Parameter RAP
565
036-540 Fax Parameter RAP
566
036-541 Fax Parameter RAP
566
036-542 Fax Parameter RAP
567
036-550 Fax Parameter RAP
567
036-700 Fax Parameter RAP
568
036-701 Fax Parameter RAP
568
036-702 Fax Parameter RAP
569
036-703 Fax Parameter RAP
569
036-704 Fax Parameter RAP
570
036-705 Fax Parameter RAP
570
036-706 Fax Parameter RAP
571
036-707 Fax Parameter RAP
571
036-708 Fax Parameter RAP
572
036-709 Fax Parameter RAP
572
036-710 Fax Parameter RAP
573
036-711 Fax Parameter RAP
573
036-712 Fax Parameter RAP
574
036-713 Fax Parameter RAP
574
036-714 Fax Parameter RAP
575
036-715 Fax Parameter RAP
575
036-716 Fax Parameter RAP
576
036-717 Fax Parameter RAP
576
036-718 Fax Parameter RAP
577
036-719 Fax Parameter RAP
577
036-720 Fax Parameter RAP
578
036-721 Fax Parameter RAP
578
036-722 Fax Parameter RAP
579
036-723 Fax Parameter RAP
579
036-724 Fax Parameter RAP
580
036-725 Fax Parameter RAP
580
036-726 Fax Parameter RAP
581
036-727 Fax Parameter RAP
581
036-728 Fax Parameter RAP
582
036-729 Fax Parameter RAP
582
036-730 Fax Parameter RAP
583
036-731 Fax Parameter RAP
583
036-732 Fax Parameter RAP
584
036-733 Fax Parameter RAP
584
036-734 Fax Parameter RAP
585
036-735 Fax Parameter RAP
585
036-736 Fax Parameter RAP
586
036-737 Fax Parameter RAP
586
036-738 Fax Parameter RAP
587
036-739 Fax Parameter RAP
587
036-740 Fax Parameter RAP
588
036-741 Fax Parameter RAP
588
036-742 Fax Parameter RAP
589
036-743 Fax Parameter RAP
589
036-744 Fax Parameter RAP
590
036-745 Fax Parameter RAP
590
036-746 Fax Parameter RAP
591
036-747 Fax Parameter RAP
591
036-748 Fax Parameter RAP
592
036-749 Fax Parameter RAP
592
036-750 Fax Parameter RAP
593
036-751 Fax Parameter RAP
593
036-752 Fax Parameter RAP
594
036-753 Fax Parameter RAP
594
036-754 Fax Parameter RAP
595
036-755 Fax Parameter RAP
595
036-756 Fax Parameter RAP
596
036-757 Fax Parameter RAP
596
036-758 Fax Parameter RAP
597
036-759 Fax Parameter RAP
597
036-760 Fax Parameter RAP
598
036-761 Fax Parameter RAP
598
036-762 Fax Parameter RAP
599
036-763 Fax Parameter RAP
599
036-764 Fax Parameter RAP
600
036-765 Fax Parameter RAP
600
036-766 Fax Parameter RAP
601
036-767 Fax Parameter RAP
601
036-768 Fax Parameter RAP
602
036-769 Fax Parameter RAP
602
036-770 Fax Parameter RAP
603
036-771 Fax Parameter RAP
603
036-772 Fax Parameter RAP
604
036-773 Fax Parameter RAP
604
036-774 Fax Parameter RAP
605
036-775 Fax Parameter RAP
605
036-776 Fax Parameter RAP
606
036-777 Fax Parameter RAP
606
036-778 Fax Parameter RAP
607
036-779 Fax Parameter RAP
607
036-780 Fax Parameter RAP
608
036-781 Fax Parameter RAP
608
036-782 Fax Parameter RAP
609
036-783 Fax Parameter RAP
609
036-784 Fax Parameter RAP
610
036-785 Fax Parameter RAP
610
036-786 Fax Parameter RAP
611
036-787 Fax Parameter RAP
611
036-788 Fax Parameter RAP
612
036-789 Fax Parameter RAP
612
036-790 Fax Parameter RAP
613
036-791 Fax Parameter RAP
613
036-792 Fax Parameter RAP
614
036-793 Fax Parameter RAP
614
036-794 Fax Parameter RAP
615
036-795 Fax Parameter RAP
615
036-796 Fax Parameter RAP
616
036-797 Fax Parameter RAP
616
036-798 Fax Parameter RAP
617
036-799 Fax Parameter RAP
617
Chain 041
618
041-310 IM Logic Failure
618
041-311 MCU PWB Fuse F2
618
041-312 MCU PWB Fuse F1
619
041-314 MCU PWB Fuse FA
619
041-319 MCU PWB Interlock Fuse F4
620
041-320 MCU PWB Interlock Fuse F3
620
041-323 MCU PWB Fuse F5
621
041-340 MCU PWB Data RAP
621
041-341 MCU PWB Access RAP
622
041-342 MCU PWB Buffer RAP
622
041-500
623
041-501
623
Chain 042
624
042-311 Auger Motor Failure RAP
624
042-313 Rear Cooling Fan Failure RAP
624
042-324 Drum Motor Drive Failure RAP
625
042-325 Main Motor Failure RAP
625
042-400 Filter Life RAP
626
Chain 045
628
045-310 Image RAP
628
045-311 Controller Communications RAP
628
045-321 Marking Panel RAP
629
045-322 Marking Pitch RAP
629
045-323 Marking Y RAP
630
045-324 Marking M RAP
630
045-325 Marking C RAP
631
045-326 Marking K RAP
631
045-327 Marking Y RAP
632
045-328 Marking M RAP
632
045-329 Marking C RAP
633
045-330 Marking K RAP
633
045-331 Marking Reject RAP
634
045-332 Marking Reject RAP
634
045-333 Marking Communication RAP
635
045-334 Marking Drive Communication RAP
635
045-335 Marking Fuser Communication RAP
636
045-336 Marking ROS Communication RAP
636
045-337 Marking Imaging Communication RAP
637
Chain 047
638
047-211 OCT 2 RAP
638
047-214 MCU Duplex Module RAP
638
047-216 MCU Finisher Communication RAP
639
Chain 061
640
061-320 ROS Motor RAP
640
061-325 SOS RAP
641
061-333 ROS Fan defect RAP
641
061-344 Video Processor RAP
642
061-345 +5 VDC Interlock RAP
642
Chain 062
644
062-210 IIT Hot Line RAP
644
062-211 IIT/IPS PWB EEPROM RAP
644
062-220 IIT/IPS PWB to ESS PWB RAP
645
062-277 IIT/IPS PWB DADF PWB Communication RAP
645
062-278 IIT/IPS PWB RAP
646
062-300 Platen Interlock Open RAP
646
062-310 IIT/IPS PWB Controller Communication RAP
647
062-311 IIT/IPS Software RAP
647
062-345 IIT/IPS Subsystem RAP
648
062-357 CCD Fan Failure RAP
648
062-360 Carriage Position RAP
649
062-362 IIT/IPS PWB RAP
650
062-371 Lamp Illumination RAP
650
062-380 Platen AGC CH1 RAP
651
062-386 Platen AOC CH1 RAP
651
062-389 Carriage Over Run RAP
652
062-392 IIT/IPS PWB Memory Failure-1 RAP
652
062-393 IIT/IPS PWB RAM RAP
653
062-500 IISS ROM RAP
653
062-790 Prohibited Document Detection RAP
654
Chain 063
656
063-210 Extension EPROM RAP
656
063-220 IIT/IPS PWB Extension PWB Sync RAP
656
063-230 Extension PWB DIMM RAP
657
063-240 Extension PWB Processing RAP
657
063-500 IISS Extension ROM RAP
658
Chain 065
660
065-210 Extension PWB DIMM RAP
660
065-211 CIS Flash ROM RAP
660
065-212 CIS Shading RAP
661
065-213 CIS Light RAP
661
065-215 Extension PWB DIMM 2 RAP
662
065-216 Extension PWB DIMM 3 RAP
662
065-219 CIS Black/White RAP
663
065-220 IF PWB Sync RAP
663
Chain 071
664
071-100 Tray 1 Pre Feed RAP
664
071-101 Tray 1 Misfeed RAP
665
071-105 Registration Sensor RAP
666
071-211 Tray 1 RAP
667
071-212 Tray 1 Ready RAP
667
071-210 Tray 1 Lift Up RAP
668
071-401 Tray 1 Feed Roll Life RAP
669
071-402 Tray 1 Feed Roll Replacement RAP
670
071-900 Tray 1 Feed Out Sensor RAP
671
071-940 Tray 1 Lift Up RAP
672
Chain 072
674
072-100 Tray 2 Pre Feed RAP
674
072-101 Tray 2 Misfeed Jam RAP
675
072-102 Tray 2 Feed Out Sensor On Jam (Tray 3 Feed) RAP
676
072-105 Tray 2 Registration Sensor On Jam RAP
677
072-210 Tray 2 Lift Up RAP
678
072-211 Tray 2 RAP
679
072-212 Tray 2 Ready RAP
680
072-401 Tray 2 Feed Roll Life RAP
681
072-402 Tray 2 Feed Roll Replacement RAP
682
072-900 Tray 2 Feed Out Sensor Jam RAP
683
072-940 Tray 2/TTM 2 Lift Up RAP
684
Chain 073
686
073-100 Tray 3 Pre Feed RAP
686
073-101 Tray 3 Misfeed Jam RAP
687
073-102 Tray 3 Feed Out Sensor On Jam RAP
689
073-105 Tray 3 Registration Sensor On Jam RAP
690
073-210 Tray 3 Lift Up RAP
691
073-211 Tray 3 RAP
692
073-212 Tray 3 Ready RAP
693
073-401 Tray 3 Feed Roll Life RAP
694
073-402 Tray 3 Feed Roll Replacement RAP
695
073-900 Tray 3 Feed Out Sensor On Jam RAP
696
073-940 Tray 3/TTM 3 Lift Up RAP
697
Chain 075
698
075-135 MSI Registration Sensor On Jam RAP
698
075-401 MSI Feed Roll Life RAP
699
075-402 MSI Feed Roll Replacement RAP
700
Chain 077
702
077-101 Registration Sensor Off Jam RAP
702
077-103 Exit Sensor 1 Off Jam (too long) RAP
703
077-104 Exit Sensor 1 Off Jam (too short) RAP
703
077-105 Exit Sensor 2 Off Jam RAP
704
077-106 Exit Sensor 1 On Jam RAP
705
077-108 Exit Gate Jam RAP
705
077-109 IOT Exit Sensor 2 On Jam RAP
706
077-110 POB Sensor On Jam RAP
707
077-123 Registration Sensor On Jam RAP
708
077-130 Duplex Out Sensor On Jam RAP
709
077-131 Duplex Wait Sensor On Jam RAP
710
077-215 Tray Module Communication RAP
711
077-300 IOT Front Cover Open RAP
712
077-301 Left Hand Interlock Open RAP
713
077-305 Tray Module Left Hand Cover Interlock Open RAP
714
077-307 DUP Cover Open RAP
715
077-308 Left Hand High Interlock Open RAP
716
077-309 Left Hand Low Interlock Open RAP
717
077-314 Tray Module Logic RAP
718
077-602 OHP Sensor RAP
718
077-900 Tray/Registration Sensor Jam RAP
719
077-901 Fuser Exit Sensor Jam RAP
720
077-902 Exit Sensor 2 On Jam RAP
721
077-903 POB Sensor JAM RAP
722
077-907 Duplex Wait Sensor RAP
723
077-967 Paper Kind Mismatch RAP
723
077-968 Paper Type Changed RAP
724
Chain 078
726
078-210 TTM Tray 2 Lift RAP
726
078-211 TTM Tray 3 Lift RAP
727
078-500 Write to HCF-ROM error detection (During DLD method)
728
078-940 Tray Lift RAP
728
078-941 TTM Tray 3 Lift RAP
730
Chain 081
732
081-799 Registered Destination RAP
732
Chain 089
734
089-311 IOT Belt Home RAP
734
089-312 IOT Belt Home RAP
734
089-630 IOT Belt Speed RAP
735
089-631 Belt Slip RAP
735
089-632 IBT Belt Cleaner RAP
736
089-633 2nd BTR RAP
736
Chain 091
738
091-313 Xero CRUM Communication RAP
738
091-400 Waste Toner Near Full RAP
738
091-402 Drum Life Over RAP
739
091-441 Drum Life Near End of Life RAP
739
091-910 Waste Toner Bottle Position RAP
740
091-911 Waste Toner Full RAP
740
091-912 Xerographics Drum Module Installation RAP
741
091-914 Xero CRUM Comm RAP
741
091-915 Xero CRUM Data RAP
742
091-916 Xero CRUM Match RAP
742
091-921 Xerographics Drum Module Installation RAP
743
091-935 Xero Drum Cartridge End of Life RAP
743
Chain 092
744
092-310 ADC Sensor RAP
744
092-934 Print Count RAP
744
092-649 ADC Shutter Open RAP
745
092-650 ADC Shutter Close RAP
745
092-651 ADC Shutter Clean RAP
746
092-661 Temperature Sensor RAP
746
092-662 Humidity Sensor RAP
747
Chain 093
748
093-310 Rotary Position Failure
748
093-311 Rotary Assembly Failure
748
093-320 Developer Motor Failure RAP
749
093-400 Black Toner Near Empty
749
093-406 Black Toner Pre-Near Empty
750
093-407 Y Toner Pre-Near Empty
750
093-408 M Toner Pre-Near Empty
751
093-409 C Toner Pre-Near Empty
751
093-414 Y Developer Housing is near End of Life
752
093-415 M Developer Housing is near End of Life
752
093-416 C Developer Housing is near End of Life
753
093-417 K Developer Housing is near End of Life
753
093-418 Y Developer Housing is Over End of Life
754
093-419 M Developer Housing is Over End of Life
754
093-420 C Developer Housing is Over End of Life
755
093-421 K Developer Housing is Over End of Life
755
093-423 Y Toner Near Empty
756
093-424 M Toner Near Empty
756
093-425 C Toner Near Empty
757
093-912 Black Toner Empty
757
093-916 Toner K CRUM not in position Failure
758
093-924 Toner K Crum Communication Failure
758
093-926 Toner K Crum Data Mismatch Failure
759
093-940 Toner Y CRUM Communication Failure
760
093-941 Toner M CRUM Communication Failure
760
093-942 Toner C CRUM Communication Failure
761
093-950 Toner Y CRUM Data Broken Failure
761
093-951 Toner M CRUM Data Broken Failure
762
093-952 Toner C CRUM Data Broken Failure
762
093-960 Toner Y CRUM Data Mismatch Failure
763
093-961 Toner M CRUM Data Mismatch Failure
763
093-962 Toner C CRUM Data Mismatch Failure
764
093-970 Toner Y CRUM not in position Failure
764
093-971 Toner M CRUM not in position Failure
765
093-972 Toner C CRUM not in position Failure
765
Chain 094
766
094-320 2nd BTR Retract RAP
766
094-321 2nd BTR Contact RAP
766
094-322 2nd BTR Retract RAP
767
094-323 2nd BTR Contact RAP
767
094-417 IBT Near End of Life RAP
768
094-418 IBT Cleaner Near End of Life RAP
768
094-419 2nd BTR Near End of Life RAP
769
094-420 IBT End of Life RAP
769
094-421 IBT Cleaner End of Life RAP
770
094-422 2nd BTR End of Life RAP
770
Chain 102
772
102-356 Controller Software RAP
772
102-380 UI Control RAP
772
102-381 UI Data Link RAP
773
102-382 Application Layer Command RAP
773
Chain 116
774
116-220
774
116-310 ESS Font DIMM #2 RAP
774
116-311 ESS Font DIMM #3 RAP
775
116-312 HDD Encrypt Key RAP
775
116-313 HDD Encrypt Setup RAP
776
116-314 Ethernet Address RAP
776
116-315 ESS DDR DIMM #1 R/W Check RAP
777
116-316 ESS DDR DIMM #2 R/W Check RAP
777
116-317 ESS ROM DIMM #1 Check RAP
778
116-318 ESS ROM DIMM #2 Check RAP
778
116-319 Controller UI Configuration
779
116-321 System Software RAP
779
116-322 WebDAV S/W Fail RAP
780
116-323 ESS NVRAM R/W Check RAP
780
116-324 System Controller RAP
781
116-325 ESS Fan RAP
781
116-328 Controller Cache RAP
782
116-329 Serial Software RAP
782
116-330 HDD File System RAP
783
116-331 Invalid Log Information RAP
783
116-332 ESS ROM RAP
784
116-333 LocalTalk Software RAP
784
116-334 ESS NVRAM Data Compare Fail RAP
785
116-335 HDD RAP
785
116-336 HDD Access RAP
786
116-337 SNTP Software RAP
786
116-338 JBA RAP
787
116-340 Memory RAP
787
116-341 ROM Version RAP
788
116-342 Network Manager RAP
788
116-343 Main PWB IC RAP
789
116-346 Formatter RAP
789
116-348 Redirector RAP
790
116-349 SIF RAP
790
116-350 AppleTalk Software RAP
791
116-351 Ether Talk Software RAP
791
116-352 NetWare Software RAP
792
116-353 HDD Mechanical RAP
792
116-354 HDD Product RAP
793
116-355 Agent Software RAP
793
116-356 HDD Format RAP
794
116-357 PostScript RAP
794
116-358 Salutation Software RAP
795
116-359 Software RAP
795
116-360 SMB Software RAP
796
116-361 Spool HDD RAP
796
116-362 SSDP Software RAP
797
116-363 Print Service Software RAP
797
116-364 Timer RAP
798
116-365 Spool RAP
798
116-366 Software Report RAP
799
116-367 Parallel Software RAP
799
116-368 Dump Print RAP
800
116-370 XJCL RAP
800
116-371 PCL Decomposer Software RAP
801
116-372 Formatter RAP
801
116-373 Dynamic DNS Software RAP
802
116-374 Auto Switch RAP
802
116-375 Formatter RAP
803
116-376 Port 9100 Software RAP
803
116-377 Video DMA RAP
804
116-378 Controller Software RAP
804
116-379 Controller Software RAP
805
116-380 ESS Font ROM DIMM #1 RAP
805
116-381 ABL Initialize RAP
806
116-382 ABL Initialize RAP
806
116-383 PIT Lib Failure RAP
807
116-385 IDC Software RAP
807
116-388 MCC RAP
808
116-389 RAM Install RAP
808
116-390 ROM NVM Mismatch RAP
809
116-391 Country Code RAP
809
116-395 USB Software RAP
810
116-399 Initialization RAP
810
116-701 Memory Duplex RAP
811
116-702 Substitute Font RAP
811
116-703 PostScript Language RAP
812
116-710 HP-GL/2 Memory Overflow RAP
812
116-711 Size/Orientation Mismatch RAP
813
116-712 Form Registration RAP
813
116-713 HDD Job Full RAP
814
116-714 HP-GL/2 Command RAP
814
116-715 Max Form to PLW Registered RAP
815
116-718 Selected PLW Form Not Registered RAP
815
116-720 PCL Memory RAP
816
116-725 The log image storage area full RAP
816
116-737 Registration RAP
817
116-738 Overlay Size Orientation RAP
817
116-739 Form/Logo Capacity RAP
818
116-740 Arithmetic RAP
818
116-741 Maximum Forms Data Register RAP
819
116-742 Max Logo Registered RAP
819
116-743 Form/Logo Size Overflow RAP
820
116-745 ART Command RAP
820
116-746 Selected Form RAP
821
116-747 Invalid Page Margin RAP
821
116-748 Page Image Data RAP
822
116-749 PostScript Font RAP
822
116-752 Print Job Ticket Description Warning RAP
823
116-771 Invalid JBIG Parameter DL Fixed RAP
823
116-772 Invalid JBIG Parameter D Fixed RAP
824
116-773 Invalid JBIG Parameter P Fixed RAP
824
116-774 Invalid JBIG Parameter YD Fixed RAP
825
116-775 Invalid JBIG Parameter L0 Fixed RAP
825
116-776 Invalid JBIG Parameter MX Fixed RAP
826
116-777 Invalid JBIG Parameter MY Fixed RAP
826
116-778 Invalid JBIG Par VLength Fixed RAP
827
116-780 Attached Document RAP
827
116-790 Stapling Canceled RAP
828
Chain 121
830
121-310 EPSV-Accessory Communication HDD RAP
830
121-333 EPSV-EP M/C Communication HDD RAP
830
121-334 EPSV Login HDD RAP
831
121-335 EPSV Wake Up Answer HDD RAP
831
121-336 Unknown EP Accessory RAP
832
121-337 EP Accessory Self Diagnostic HDD RAP
832
121-338 EPSV Answer Time Out RAP
833
121-339 Changed Price Table RAP
833
121-340 EP Accessory Mismatch RAP
834
121-350 EPSV Logic HDD RAP
834
121-370 EP-DX RAP
835
Chain 123
836
123-203 UI Controller RAP
836
123-207 Communication Manager Target RAP
836
123-209 Controller UI Communication RAP
837
123-310 Send Queue RAP
837
123-311 Receive Queue RAP
838
123-317 Receive Message Queue RAP
838
123-318 Receive Finish Queue RAP
839
123-322 UI Target RAP
839
123-323 UI Address RAP
840
123-325 Object Creation RAP
840
123-326 Memory Overflow RAP
841
123-327 Button Overflow RAP
841
123-328 UI Internal Range RAP
842
123-329 UI Coordinates RAP
842
123-332 Interface Parameter RAP
843
123-333 Interface Communication RAP
843
123-337 Frame Data RAP
844
123-341 Event Queue RAP
844
123-342 Event Queue RAP
845
123-343 Invalid Class RAP
845
123-344 Invalid Type RAP
846
123-345 Timer Queue Full RAP
846
123-346 Invalid Timer Number RAP
847
123-350 Privilege Command RAP
847
123-362 Object RAP
848
123-368 UI Memory RAP
848
123-369 Interface Value RAP
849
123-370 Interface Length RAP
849
123-371 Interface Parameter RAP
850
123-372 Interface Sequence RAP
850
123-373 Channel RAP
851
123-374 User Job ID RAP
851
123-375 Internal Resource RAP
852
123-376 Internal Memory RAP
852
123-377 UI Timer RAP
853
123-378 Interface Format RAP
853
123-379 Dispatch RAP
854
123-380 Copy Interface RAP
854
123-381 Fax Interface RAP
855
123-382 Scanner Interface RAP
855
123-383 Report Interface RAP
856
123-384 Server Access RAP
856
123-385 Service Object RAP
857
123-386 Service Object RAP
857
123-387 Service Object RAP
858
123-388 Attribute RAP
858
123-389 UI Comparator RAP
859
123-390 Job Parameter RAP
859
123-391 Job Parameter RAP
860
123-392 Auditron RAP
860
123-393 UI Compiling RAP
861
123-394 File Access RAP
861
123-395 UI NVM RAP
862
123-396 UI Software RAP
862
123-397 UI Manager RAP
863
123-398 Release Queue RAP
863
123-399 UI Internal RAP
864
123-400 Internal Interface RAP
864
Chain 124
866
124-310 Product Designation RAP
866
124-311 Product Serial Number RAP
866
124-312 Machine Codes Mismatch RAP
867
124-313 Serial Number RAP
867
124-314 IOT Speed RAP
868
124-315 Serial Number Mismatch RAP
868
124-316 Product Mode RAP
869
124-317 All Product Mode RAP
869
124-318 Product Type Software Key RAP
870
124-319 All Product Types Software Key RAP
870
124-320 EPROM RAP
871
124-321 Backup SRAM RAP
871
124-322 Software Key RAP
872
124-323 Software Key Registration RAP
872
124-324 All Billings Mismatch RAP
873
124-325 Billing Restoration RAP
873
124-333 ASIC RAP
874
124-334 Standard Font ROM RAP
874
124-335 Font ROM RAP
875
124-337 ESS Standard RAM RAP
875
124-338 Duplicate Font ROMs RAP
876
124-339 ROM DIMM Mismatch RAP
876
124-340 CRUM Market RAP
877
124-341 CRUM Market MCU RAP
877
124-342 CRUM Market System 1 RAP
878
124-343 CRUM Market System 2 RAP
878
124-350 CRUM OEM RAP
879
124-351 CRUM OEM MCU RAP
879
124-352 CRUM OEM System 1 RAP
880
124-353 CRUM OEM System 2 RAP
880
124-360 CRUM Validation RAP
881
124-361 CRUM Validation MCU RAP
881
124-362 CRUM Validation System 1 RAP
882
124-363 CRUM validation System 2 RAP
882
124-372 IOT Controller Software RAP
883
124-373 IOT Manager Software RAP
883
124-374 IOT IM Device Driver Software RAP
884
124-380 CRUM Market (2)
884
124-381 CRUM Market MCU (2)
885
124-382 CRUM Market System 1 (2)
885
124-383 CRUM Market System 2 (2)
886
124-390 OEM Market (2)
886
124-391 CRU OEM MCU (2)
887
124-392 CRU OEM System 1 (2)
887
124-393 CRU OEM System 2 (2)
888
124-701 Side Tray to Center Tray RAP
888
124-702 Finisher Tray to Center Tray RAP
889
124-709 Side Tray to Center Tray RAP
889
Chain 125
890
125-311 PSW Unexpected Fail RAP
890
Chain 127
892
127-310 ESR Task RAP
892
127-337 Job Template HDD Write RAP
892
127-342 Job Template Monitor RAP
893
127-353 LPD Software RAP
893
127-354 FTP Server Software RAP
894
127-396 Mail I/O Software RAP
894
127-398 IPP Software RAP
895
127-399 JME Software RAP
895
Chain 133
896
133-210 Fax Parameter RAP
896
133-211 Fax Parameter Value Invalid RAP
896
133-212 Fax Read Error- No Data RAP
897
133-213 Fax Read Error- Invalid Data RAP
897
133-214 Fax USB Initializing RAP
898
133-215 Fax USB Device RAP
898
133-216 Fax USB Host Fatal RAP
899
133-217 Fax Manager Short of Memory RAP
899
133-218 Fax Card Message Library Short of Memory RAP
900
133-219 Fax Work Memory RAP
900
133-220 Fax Control Task RAP
901
133-221 Fax Card Boot RAP
901
133-222 Fax Card does not respond intervalley RAP
902
133-223 Fax Card Reset RAP
902
133-224 Controller ROM Fax Card ROM RAP
903
133-226 Country Code RAP
903
133-280 Fax Option Slot 1 Board RAP
904
133-281 Received unknown message RAP
904
133-282 Fax Card Download RAP
905
133-283 Fax Report Mailbox RAP
905
Chain 134
906
134-210 Fax Controller Parameter RAP
906
134-211 FCB PWB RAP
906
Chain 202
908
202-399 Internal Timer RAP
908
Other Faults
910
OF 1 Paper Size Mismatch In Width RAP
910
OF 2 Size Switch Assy RAP
911
OF 3 Main Drive Assy RAP
912
OF 4 Fuser Drive Assy RAP
913
OF 5 Developer Motor RAP
914
OF 6 Dark / Blank Display RAP
915
3 Image Quality
916
IOT Image Quality Entry RAP
918
IQ1 IOT Image Quality Entry RAP
918
IQ2 IIT Image Quality Entry RAP
920
IQ3 Low Image Density/Nearly Blank/Uneven Density RAP
921
IQ4 Wrinkled Image RAP
922
IQ5 Residual Image (Ghosting) RAP
923
IQ6 IOT Background RAP
923
IQ7 Deletions RAP
924
IQ8 Color-to-Color Misregistration RAP
924
IQ9 Skew/Misregistration RAP
925
IQ12 Process Direction Bands, Streaks, and Smears RAP
926
IQ13 Unfused Copy/Toner Offset RAP
927
IQ14 Repeating Bands, Streaks, Spots, and Smears RAP
928
IQ15 Mottle RAP
929
IQ16 Spots RAP
930
IQ17 Missing Colors RAP
931
IQ21 Developer Bias/1st BTR RAP
931
Image Quality Specifications
933
Image Quality Specifications
933
Image Defect Samples
936
Image Defect Samples
936
Background
936
Color Misregistration
937
Debris-Centered Deletions
937
Deletions
938
High Frequency Bands
938
Irregular Process Direction Streak
939
Low Image Density
939
Moire
940
Mottle
940
Newton Rings
941
Regular (Repeating) Bands, Streaks, Spots, or Smears
941
Residual Image
942
Streak Deletion in Process Direction
942
Wrinkled Image
943
Worm Defect
943
Auger Marks Defect (Black)
944
Auger Marks Defect (Magenta)
945
59mm Pitch Density Non-Uniformity Defect
946
201mm Streaks from the lead edge Defect
947
M, C, K Banding Defect
948
103mm Streaks from the lead edge Defect
949
Scratches on Transparency Defect
950
Toner Soft Blocking Defect
950
Toner Dam Ghosting Defect
951
4 Repairs and Adjustments
952
4 Repair Procedure
952
1. Drives
954
REP 1.1.1 Main Drive Assembly
954
REP 1.1.2 Drum Drive Assembly
961
2. Paper Transportation
964
REP 2.1.1 Tray 1 Feeder
964
REP 2.1.1 Tray 1 Feeder
964
REP 2.3.1 Tray 1 Feed/Nudger/Retard Roll
966
REP 2.3.1 Tray 1 Feed/Nudger/Retard Roll
966
REP 2.4.1 Registration Unit
968
REP 2.4.1 Registration Unit
968
REP 2.5.1 Takeaway Roll
969
REP 2.5.1 Takeaway Roll
969
REP 2.6.2 L/H Upper Cover Unit
971
3. ROS
972
REP 3.1.1 ROS Unit
972
4. Xerograghics/Development
974
REP 4.1.1 Developer Housing
974
REP 4.1.2 Toner Cartridge
977
REP 4.1.3 Developer Bias Brush
978
REP 4.1.4 Waste Toner Auger
979
REP 4.2.1 Developer Motor Assembly
980
REP 4.2.2 IBT Module
981
REP 4.2.3 Print Drum
986
REP 4.2.4 IBT Cleaner
987
REP 4.2.5 IBT Belt
988
REP 4.2.6 Rotary Drive Motor
993
REP 4.2.7 Developer Material
994
REP 4.2.8 2nd BTR Contact Arms
999
REP 4.3.1 Sensor Bar
1001
5. Fuser
1002
REP 5.1.1 Fuser Unit
1002
6. Exit
1004
REP 6.1.1 Exit2 + OCT2
1004
7. MPT
1006
REP 7.1.1 MSI Assembly
1006
REP 7.2.1 MSI Feed Roll/Retard Pad
1008
9. Electrical Components
1010
REP 9.1.1 MCU PWB
1010
REP 9.1.2 MCU PWB EPROM
1012
REP 9.2.1 ESS PWB
1013
REP 9.2.2 ESS PWB EPROM
1018
REP 9.2.3 Power Supply PWB
1018
REP 9.2.4 Print Chassis Assembly
1019
REP 9.2.5 PS DIMM
1020
10. Covers
1022
REP 10.1.1 Top Cover Assembly
1022
REP 10.2.1 Rear Lower Covers
1023
REP 10.2.2 Front Inner Cover
1025
REP 10.2.3 Right Side Cover
1026
REP 10.3.1 Rear Fan
1027
11. IIT
1028
REP 11.1.1 Platen Cushion
1028
REP 11.1.2 Control Panel Assembly
1029
REP 11.3.1 Platen Glass
1029
REP 11.3.2 IIT/IPS PWB
1030
REP 11.4.1 Lens Kit Assembly
1035
REP 11.5.1 Carriage Cable
1037
REP 11.5.2 Carriage Motor Assembly
1043
REP 11.6.1 Exposure Lamp
1047
REP 11.6.2 Lamp Wire Harness
1048
12. Tray Module - 2TM
1052
REP 12.1.1 Tray 2 Feeder (2TM)
1052
REP 12.1.2 Tray 3 Feeder (2TM)
1055
REP 12.3.1 Feed/Retard/Nudger Roll (2TM)
1058
REP 12.6.1 2TM PWB
1059
13. Tray Module TTM
1062
REP 13.1.1 Tray 2 Assembly (TTM)
1062
REP 13.1.2 Tray 3 Assembly (TTM)
1063
REP 13.3.1 Front/Rear Tray Cable (TTM)
1064
REP 13.4.1 Tray 3 Feeder (TTM)
1065
REP 13.5.1 Tray 2 Feeder (TTM)
1068
REP 13.6.1 Feed/Retard/Nudger Roll (TTM)
1070
REP 13.8.1 TTM PWB
1071
15. DADF
1074
REP 15.1.1 DADF
1074
REP 15.1.2 DADF Platen Cushion
1076
REP 15.2.1 DADF Document Tray
1077
REP 15.2.2 DADF Feeder Assembly
1079
REP 15.2.3 DADF Front Cover
1081
REP 15.2.4 DADF Rear Cover
1081
REP 15.3.1 DADF PWB
1083
REP 15.3.2 Left Counter Balance
1084
REP 15.3.3 Right Counter Balance
1085
REP 15.4.1 Retard Roll
1086
REP 15.4.2 Top Cover Assembly
1088
REP 15.6.1 Nudger Roll, Feed Roll
1093
REP 15.8.1 Registration Roll
1098
16. Finisher
1102
REP 16.1.1 H-Transport Assembly
1102
REP 16.1.2 Finisher Assembly
1102
REP 16.3.1 H-Transport Belt
1106
REP 16.4.1 Front Cover Assembly
1108
REP 16.4.2 Rear Cover
1109
REP 16.5.1 Stack Height Sensor Assembly
1110
REP 16.5.2 Eject Roll Assembly
1111
REP 16.6.1 Decurler Roll
1117
REP 16.6.2 Finisher Drive Motor
1119
REP 16.7.1 Paper Eject Belt
1119
REP 16.8.1 Staple Unit Rail
1122
REP 16.8.2 Staple Assembly
1127
REP 16.9.1 Compiler Tray Assembly
1128
REP 16.10.1 Stacker Motor Assembly
1130
REP 16.10.2 Elevator Belt Assembly
1132
REP 16.11.1 Paddle Gear Shaft
1133
REP 16.12.1 Finisher PWB
1135
REP 16.12.2 Finisher LVPS PWB
1136
REP 22.1 A-Finisher
1144
Figure 1 Disconnecting the Connectors (af422104)
1144
Figure 2 Loosen the Thumb Screws (af422105)
1144
Figure 3 Remove the A-Finisher (af422106)
1145
REP 22.3.1 Paddle Belt
1145
Figure 1 Removing the Pulley (j0fa42201)
1145
Figure 2 Removing the Bearing (j0fa42202)
1146
Figure 3 Removing the Gear (j0fa42203)
1146
Figure 4 Removing the Bearing (j0fa42204)
1146
Figure 5 Removing the Paddle Link Assembly (j0fa42205)
1146
Figure 6 Removing Bearing (0fa42206)
1147
Figure 7 Removing Shaft Assembly (j0fa42207)
1147
Figure 8 Removing the Paddle Belt (j0fa42208)
1147
Figure 9 Installing the Paddle Link Assembly (j0fa42209)
1147
REP 22.3.2 Sub Paddle Solenoid
1148
Figure 1 Disconnecting the Connector (j0fa42210)
1148
Figure 2 Removing the Sub Paddle Solenoid Assembly (j0fa42211)
1148
Figure 3 Removing the Support (j0fa42212)
1148
Figure 4 Removing the Sub Paddle Solenoid (j0fa42213)
1149
Figure 5 Installing the Sub Paddle Assembly (j0fa42214)
1149
REP 22.4.1 Exit Roll Assembly
1149
Figure 1 Removing the Gear (j0fa42215)
1149
Figure 2 Removing the Bearing (j0fa42216)
1150
Figure 3 Removing the Bearing (j0fa42217)
1150
Figure 4 Removing the Exit Roll Assembly (j0fa42218)
1150
REP 22.4.2 Staple Assembly
1151
Figure 1 Removing the Staple Assembly (j0fa42219)
1151
Figure 2 Removing the Bracket (j0fa42220)
1151
REP 22.4.3 Set Clamp Home Sensor
1152
Figure 1 Disconnecting Connector (j0fa42221)
1152
Figure 2 Removing the Set Clamp Home Sensor Assembly (j0fa42222)
1152
Figure 3 Removing the Set Clamp Home Sensor (j0fa42223)
1152
REP 22.4.4 Exit Roll Assembly
1153
Figure 1 Removing the Upper Frame Section (af422101)
1153
Figure 2 Removing the Upper Chute Assembly (af422100)
1154
Figure 3 Removing the Exit Roll Assembly (af422103)
1154
REP 22.5.1 Pinch Roll
1155
Figure 1 Removing the Pinch Rolls (j0fa42224)
1155
REP 22.5.2 Finisher Entrance Sensor
1155
Figure 1 Removing the Connector Bracket (j0fa42266)
1155
Figure 2 Removing the Bottom Plate (j0fa42267)
1156
Figure 3 Removing the Finisher Entrance Sensor Assembly (j0fa42225)
1156
Figure 4 Removing the Finisher Entrance Sensor (j0fa42226)
1156
REP 22.5.3 Compile Exit Sensor
1157
Figure 1 Removing the Connector Bracket (0fa42266)
1157
Figure 2 Moving the Bottom Plate (j0fa42267)
1157
Figure 3 Removing the Compile Exit Sensor Assembly (j0fa42227)
1157
Figure 4 Removing the Compile Exit Sensor (j0fa42228)
1158
REP 22.5.4 Main Paddle Shaft Assembly
1158
Figure 1 Removing the Gear (j0fa42292)
1158
Figure 2 Removing the Gear Pulley (j0fa42293)
1159
Figure 3 Removing the Bearing (j0fa42294)
1159
Figure 4 Removing the Support Bearing (j0fa42232)
1159
Figure 5 Removing the Main Paddle Shaft Assembly (j0fa42233)
1159
Figure 6 Removing the Support Bearing (j0fa42234)
1160
REP 22.5.5 Lower Chute Assembly
1160
Figure 1 Removing the Stapler Assembly (j0fa42219)
1160
Figure 2 Removing the Transport Motor (j0fa42236)
1161
Figure 3 Removing the Gear (j0fa42229)
1161
Figure 4 Removing the Gear Pulley (j0fa42230)
1161
Figure 5 Removing the Bearing (j0fa42231)
1161
Figure 6 Removing the ENT Lower Chute Assembly (j0fa42237)
1162
REP 22.6.1 ENT Roll Assembly
1162
Figure 1 Removing the Upper Frame Section (af422101)
1163
Figure 2 Removing the Upper Chute Assembly (af422100)
1163
Figure 3 Removing the Gear (af422102)
1164
REP 22.6.2 Upper Chute Assembly
1164
Figure 1 Removing the Upper Frame Section (af422101)
1165
Figure 2 Removing the Upper Chute Assembly (af422100)
1165
REP 22.7.1 Finisher Control PWB
1166
Figure 1 Removing the Finisher Control PWB (j0fa42245)
1166
REP 22.8.1 Stacker Tray Assembly
1166
Figure 1 Disconnecting the Connector (j0fa42247)
1166
Figure 2 Disconnecting the Wire (j0fa42248)
1167
Figure 3 Removing the Stacker Sensor Assembly (j0fa42249)
1167
Figure 4 Removing the Stacker Tray Assembly (j0fa42250)
1167
Figure 5 Installing the Stacker Tray Assembly (j0fa42251)
1167
REP 22.8.2 Stacker Shaft Assembly
1168
Figure 1 Removing the Bracket (j0fa42252)
1168
Figure 2 Removing the Bracket (j0fa42253)
1168
Figure 3 Removing the Top Tray (j0fa42254)
1168
Figure 4 Disconnecting the Connector (j0fa42255)
1169
Figure 5 Removing the Stacker Stack Sensor Assembly (j0fa42256)
1169
Figure 6 Removing the Stacker Assembly (j0fa42257)
1169
Figure 7 Removing the Actuator (j0fa42258)
1169
Figure 8 Moving the Bearing (j0fa42259)
1170
Figure 9 Removing the Stacker Shaft Assembly (j0fa42260)
1170
REP 22.8.3 Stacker Motor
1170
Figure 1 Disconnecting the Connector (j0fa42261)
1170
Figure 2 Removing the Bracket (j0fa42262)
1171
Figure 3 Removing the Stacker Motor Assembly (j0fa42263)
1171
Figure 4 Removing the Stacker Motor (j0fa42264)
1171
Figure 5 Installing the Stacker Motor (j0fa42265)
1171
REP 22.8.4 Stacker Stack Sensor
1172
Figure 1 Removing the Stacker Stack Sensor Assembly (af422108)
1172
REP 22.9.1 Compile Assembly
1172
Figure 1 Removing the Connector Bracket (j0fa42266)
1172
Figure 2 Removing the Bottom Plate (j0fa42267)
1173
Figure 3 Releasing the Clamp (j0fa42268)
1173
Figure 4 Removing the Stacker Tray (af422107)
1173
Figure 5 Removing the Tapping Screw (j0fa42269)
1173
Figure 6 Removing the Screw (j0fa42270)
1174
Figure 7 Removing the Compile Assembly (j0fa42271)
1174
REP 22.9.2 Set Clamp Shaft
1174
Figure 1 Removing the Bracket Assembly (j0fa42272)
1174
Figure 2 Removing the KL-Clips (j0fa42273)
1175
Figure 3 Removing the Eject Shaft (j0fa42274)
1175
Figure 4 Removing the Actuator and Bearing (j0fa42275)
1175
Figure 5 Removing the Bearing (j0fa42276)
1175
Figure 6 Removing the Set Clamp Shaft (j0fa42277)
1176
Figure 7 Installing the Eject Belt (j0fa42278)
1176
REP 22.9.3 Eject Belt
1176
Figure 1 Moving the Eject Home Sensor Assembly (j0fa42279)
1176
Figure 2 Removing the Eject Belt (j0fa42280)
1177
Figure 3 Installing the Eject Belt (j0fa42278)
1177
REP 22.9.4 Eject/Set Clamp Motor Assembly
1177
Figure 1 Removing the Connector Bracket (j0fa42266)
1177
Figure 2 Removing the Bottom Plate (j0fa42267)
1178
Figure 3 Removing the Stacker Tray (af422107)
1178
Figure 4 Removing Screws (j0fa42281)
1178
Figure 5 Removing the Eject/Set Clamp Motor Assembly (j0fa42282)
1178
REP 22.9.5 Rear Tamper Home Sensor
1179
Figure 1 Removing the Connector Bracket (j0fa42266)
1179
Figure 2 Moving the Bottom Plate (j0fa42267)
1180
Figure 3 Removing the Rear Tamper Home Sensor Assembly (j0fa42283)
1180
Figure 4 Removing the Rear Tamper Home Sensor (j0fa42284)
1180
REP 22.9.6 Eject Shaft Assembly
1181
Figure 1 Removing the Bracket Assembly (j0fa42272)
1181
Figure 2 Removing the KL-Clips (j0fa42273)
1181
Figure 3 Removing the Eject Shaft (j0fa42274)
1181
Figure 4 Installing the Eject Belt (j0fa42278)
1182
REP 22.10.1 Front /Rear Tamper Motor Assembly
1182
Figure 1 Removing the Bracket Assembly (j0fa42272)
1182
Figure 2 Removing the KL-Clips (j0fa42273)
1183
Figure 3 Removing the Eject Shaft (j0fa42274)
1183
Figure 4 Removing the Front/Rear Tamper Motor Assembly (j0fa42285)
1183
Figure 5 Installing the Eject Belt (j0fa42278)
1183
REP 22.10.2 Front Tamper Home Sensor
1184
Figure 1 Removing the Connector Bracket (j0fa42266)
1184
Figure 2 Removing the Bottom Plate (j0fa42267)
1184
Figure 3 Removing the Front Tamper Home Sensor Assembly (j0fa42286)
1184
Figure 4 Removing the Front Tamper Home Sensor (j0fa42287)
1185
REP 22.10.3 Eject Clamp Home Sensor
1185
Figure 1 Removing the Connector Bracket (j0fa42266)
1185
Figure 2 Removing the Bottom Plate (j0fa42267)
1186
Figure 3 Removing the Eject Home Sensor (j0fa42288)
1186
REP 22.10.4 Stack Height Sensor
1186
Figure 1 Removing the Connector Bracket (j0fa42266)
1186
Figure 2 Removing the Bottom Plate (j0fa42267)
1187
Figure 3 Removing the Stacker Tray (af422107)
1187
Figure 4 Removing the Bracket Assembly (j0fa42272)
1187
Figure 5 Removing the Stack Height Sensor (j0fa42289)
1187
Adjustments
1188
7. MPT
1188
ADJ 7.1.1 MSI (Bypass) Tray Guide Adjustment
1188
9. Xerographics
1190
ADJ 9.1.0 Toner Density Adjustment
1190
ADJ 9.1.1 IOT Image Registration
1190
ADJ 9.1.2 Max Setup
1193
ADJ 9.1.6 TRC Adjustment
1194
ADJ 9.1.7 Color-To-Color Registration
1194
ADJ 9.1.8 IIT Calibration
1198
ADJ 9.1.9 Optical Axis Alignment
1200
ADJ 9.1.10 Procon ON/OFF Print
1201
ADJ 9.2.1 Edge Erase Value Adjustment
1206
ADJ 9.3.1 Software Loading and Upgrading
1206
11. IIT
1208
ADJ 11.1.1 IIT Lead Edge/Side Edge Registration
1208
ADJ 11.1.2 IIT Vertical/Horizontal Magnification
1209
ADJ 11.2.1 Reduce/Enlarge Adjustment
1210
ADJ 11.3.1 UI Alignment
1211
ADJ 11.6.1 Full/Half Rate Carriage Position Adjustment
1212
15. DADF
1216
ADJ 15.1.1 DADF Side Edge Registration
1216
ADJ 15.1.3 DADF Non-Standard Sized Original Customized Registration Function
1217
ADJ 15.1.4 DADF Lead Edge Registration
1218
ADJ 15.1.5 DADF Height Adjustment
1220
ADJ 15.1.6 DADF Position (Skew) Adjustment
1221
5 Parts List
1230
Parts List Introduction
1226
Introduction
1226
Subsystem Information
1227
Symbology
1228
Drives
1230
PL 1.1 Main Drive
1230
PL 1.2 Drum Drive Assembly
1231
Tray, Feeder Assembly
1232
PL 2.1 Tray, Feeder Assembly
1232
PL 2.2 Tray 1
1233
PL 2.3 Feeder 1 Assembly (1 of 2)
1234
PL 2.4 Feeder 1 Assembly (2 of 2)
1235
PL 2.5 Registration
1236
PL 2.6 Vertical Transport Cover
1237
PL 2.7 Left Hand Cover
1238
ROS
1239
PL 3.1 ROS
1239
Drum Assembly, Waste Bottle Assembly
1240
PL 4.1 Drum Assembly, Waste Bottle Assembly
1240
PL 4.2 Waste Bottle Guide Assembly
1241
Developer Component
1242
PL 5.1 Developer Component
1242
PL 5.2 Developer Housing, Developer Cartridge
1243
IBT, 2nd BTR, IBT Cleaner Assembly
1244
PL 6.1 IBT, 2nd BTR, IBT Cleaner Assembly
1244
PL 6.2 IBT Belt Assembly
1245
Fuser Unit
1246
PL 7.1 Fuser Unit
1246
PL 7.2 Fuser Component
1247
Exit
1248
PL 8.1 Exit
1248
PL 8.2 Exit 1
1249
PL 8.3 L/H Upper Chute Assembly (Exit 2)
1250
PL 8.4 Tray Guide Assembly (OCT 2)
1251
MSI Assembly
1252
PL 9.1 MSI Assembly
1252
PL 9.2 Lower Frame Assembly
1253
PL 9.3 MSI Tray Assembly
1254
Duplex
1255
PL 10.1 Duplex
1255
PL 10.2 Inner Chute Assembly
1256
Electrical
1257
PL 11.1 Electrical
1257
PL 11.2 ESS
1258
PL 11.3 FAX Unit
1259
PL 11.4 Wire Harnesses
1260
Cover-Front, Left
1261
PL 12.1 Cover-Front, Left
1261
PL 12.2 Cover-Rear, Right
1262
Platen Cover/IIT Assembly
1263
PL 13.1 Platen Cover/IIT Assembly
1263
PL 13.2 Control Panel
1264
PL 13.3 Platen Glass
1265
PL 13.4 CCD PWB, Sensor
1266
PL 13.5 Carriage Cable/Motor
1267
PL 13.6 Full/Half Rate Carriage
1268
Tray 2/3 Assembly, Feeder Assembly-2TM
1269
PL 14.1 Tray 2/3 Assembly, Feeder Assembly-2TM
1269
PL 14.2 Tray 2/3 Assembly-2TM
1270
PL 14.3 Feeder 1/2 Assembly 2TM (1 of 2)
1271
PL 14.4 Feeder 1/2 Assembly 2TM (2 of 2)
1272
PL 14.5 Left Cover-2TM
1273
PL 14.6 Takeaway Roll-2TM
1274
PL 14.7 Electrical-2TM
1275
PL 14.8 Cover-2TM
1276
Tray 2/3, feeder Assembly-TTM
1277
PL 15.1 Tray 2/3, feeder Assembly-TTM
1277
PL 15.2 Tray 2 Assembly-TTM
1278
PL 15.3 Tray 3 Assembly-TTM
1279
PL 15.4 Paper Feed (1 of 2)-TTM
1280
PL 15.5 Paper Feed (2 of 2)-TTM
1281
PL 15.6 Feeder 1 Assembly (1 of 2)
1282
PL 15.7 Feeder 1 Assembly (2 of 2)
1283
PL 15.8 Left Cover-TTM
1284
PL 15.9 Electrical-TTM
1285
PL 15.10 Cover-TTM
1286
DADF Accessory
1287
PL 16.1 DADF Accessory
1287
PL 16.2 DADF Component Cover
1288
PL 16.3 DADF Base Cover
1289
PL 16.4 DADF Feeder Component
1290
PL 16.5 Top Cover Component
1291
PL 16.6 Takeaway Pinch Roll, Nudger Motor, Nudger/Feed Roll
1292
PL 16.7 DADF Feeder-Chute
1293
PL 16.8 DADF Feeder-Roll
1294
PL 16.9 Motor Unit Assembly
1295
PL 16.10 DADF Document Tray
1296
Finisher Units
1297
PL 17.1 Finisher Unit
1297
PL 17.2 H-Transport Assembly (1 of 2)
1298
PL 17.3 H-Transport Assembly (2 of 2)
1299
PL 17.4 Cover
1300
PL 17.5 Top Open Cover and Eject Roll
1301
PL 17.6 Paper Transport (1 of 2)
1302
PL 17.7 Paper Transport (2 of 2)
1303
PL 17.8 Staple Unit
1304
PL 17.9 Compiler Tray Assembly
1305
PL 17.10 Elevator
1306
PL 17.11 Exit
1307
PL 17.12 Electrical
1308
PL 17.13 LVPS
1309
PL 17.14 Rack
1310
PL 22.1 Finisher Assembly (Part 1 of 2)
1311
PL 22.2 Finisher Assembly (Part 2 of 2)
1312
PL 22.3 Stacker Base Assembly (Part 1 of 5)
1313
PL 22.4 Stacker Base Assembly (Part 2 of 5)
1314
PL 22.5 Stacker Base Assembly (Part 3 of 5)
1315
PL 22.6 Stacker Base Assembly (Part 4 of 5)
1316
PL 22.7 Stacker Base Assembly (Part 5 of 5)
1317
PL 22.8 Stacker Tray Assembly
1318
PL 22.9 Compile Assembly (Part 1 of 2)
1319
PL 22.10 Compile Assembly (Part 2 of 2)
1320
Common Hardware
1321
6 General Procedures
1326
UI Diagnostic Mode
1326
Reports
1328
Failure Report
1328
Shutdown Report
1329
Diagnostics
1330
NVM Read/Write
1330
IOT NVM List
1332
IIT NVM List
1398
Controller & Fax NVM List
1414
Job Flow Service
1492
Analog Monitor
1493
Other Diagnostics
1494
Serial Number/Billing Meter Data
1494
Printing HFSI
1494
Initialize HFSI Counters
1495
Adjust Toner Density
1498
MSI Guide Adjustment
1498
Initialize NVM
1499
Component Control
1500
Hard Disk Diagnostic Program
1519
Test Pattern Print
1519
Webpage Administrator Password
1520
Center Tray Offsetting
1521
E-Mail Icon
1521
FAX Output Separation
1522
General Procedures
1524
GP 1 Intermittent Problem RAP
1524
GP 2 Fax Diagnostics
1525
GP 3 Resetting the Administrator Password
1527
GP 4 Replacing Billing PWBs
1527
GP 5 Printing Reports
1528
GP 6 Special Boot Modes
1529
GP 7 Country Code Setting
1530
GP 8 Firmware Version
1530
GP 9 Save and Restore
1531
GP 10 Loading And Upgrading Software
1532
GP 11Software Option Installation and Removal
1533
GP 12 Elan Boot Sequence
1535
GP 13 Network Scanning Template Removal and Repository Reset Procedure
1536
GP 14 Setup and Scan to PWS
1537
GP 15 Clearing a 092-310 Fault Code (ADC fail)
1542
General Information
1544
Space Requirements
1544
Product Specs.
1545
Common Tools
1547
Product Tools and Test Patterns
1548
Log Book Storage
1548
Cleaning Materials
1549
Machine Consumables
1549
Glossary of Terms
1550
Change Tag Introduction
1554
7 Wire Data
1558
Plug/Jack Locations
1558
How to use the Plug/Jack Location List
1558
Plug/Jack Location List
1558
Plug/Jack Illustrations
1563
Figure 1 Control Panel
1563
Figure 2 IIT
1564
Figure 3 HVPS, IOT Front View
1565
Figure 4 ROS Unit
1566
Figure 5 Exit 2
1567
Figure 6 Fuser Assembly
1568
Figure 7 Duplex Unit, MSI
1569
Figure 8 Regi Sensor, Regi Clutch
1570
Figure 9 L/H Lower, Tray 1/2 Feeder
1571
Figure 10 ESS
1572
Figure 11 Left Side of IOT
1573
Figure 12 FAX Box Assembly
1574
Figure 13 IOT Rear Location
1575
Figure 14 MCU PWB
1576
Figure 15 AC Input
1577
Figure 16 LVPS
1578
Figure 17 Tray 2/3 Feeder (2TM)
1579
Figure 18 2TM Rear Location
1580
Figure 19 Tray 2/3 Feeder (TTM)
1581
Figure 20 TTM Rear Location
1582
Figure 21 DADF 1 of 2
1583
Figure 22 DADF 2 of 2
1584
Figure 23 H-Transport Assembly
1585
Figure 24 Finisher Front Location
1586
Figure 25 Finisher Rear Location
1587
Figure 26 Finisher PWB
1588
Plug/Jack Locations A-Finisher
1590
How to use the Plug/Jack Location List
1590
Plug/Jack Location List
1590
Plug/Jack Illustrations
1591
Figure 1 A-Finisher Front Location
1591
Figure 2 A-Finisher PWB Location
1591
Figure 3 A-Finisher Bottom Location
1592
Wire Net AC POWER (HOT)
1594
7.3.1 Wire Net AC POWER (HOT)
1594
7.3.2 Wire Net AC POWER (NUT)
1595
7.3.3 Wire Net +3.3VDC (Standby, Standby RTN)
1596
7.3.4 Wire Net +3.3VDC (Main, Main RTN)
1597
7.3.5 Wire Net +5VDC (Standby, Standby RTN)
1598
7.3.6 Wire Net +5VDC (Main)-1
1599
7.3.7 Wire Net +5VDC (Main)-2
1600
7.3.8 Wire Net +5VDC-3
1601
7.3.9 Wire Net +5VDC-4
1602
7.3.10 Wire Net +5VDC-5
1603
7.3.11 Wire Net +5VDC-6
1604
7.3.12 Blank
1605
7.3.13 Blank
1606
7.3.14 Wire Net DC COM (+5VRTN)-1
1607
7.3.15 Wire Net DC COM (+5VRTN)-2
1608
7.3.16 Wire Net DC COM (+5VRTN)-3
1609
7.3.17 Wire Net DC COM (+5VRTN)-4
1610
7.3.18 Wire Net DC COM (+5VRTN)-5
1611
7.3.19 Wire Net DC COM (+5VRTN)-6
1612
7.3.20 Wire Net DC COM (+5VRTN)-7
1613
7.3.21 Blank
1614
7.3.22 Wire Net +24VDC-1
1615
7.3.23 Wire Net +24VDC-2
1616
7.3.24 Wire Net +24VDC-3
1617
7.3.25 Wire Net +24VDC-4
1618
7.3.26 Wire Net +24VDC-5
1619
7.3.27 Wire Net +24VDC-6
1620
7.3.28 Wire Net DC COM (+24VRTN)-1
1621
7.3.29 Wire Net DC COM (+24VRTN)-2
1622
7.3.30 Wire Net DC COM (+24VRTN)-3
1623
7.3.31 Blank
1624
7.3.32 Finisher Wire Net +5VDC
1625
7.3.33 Finisher Wire Net DC COM(+5VRTN)
1626
7.3.34 Finisher Wire Net +24VDC
1627
7.3.35 Finisher Wire Net DC COM (+24VRTN)
1628
7.2.36 A-Finisher Wire Net +5VDC
1630
7.2.37 A-Finisher Wire Net DC COM(+5VRTN)
1631
7.2.38 A-Finisher Wire Net +24VDC
1632
7.2.39 A-Finisher Wire Net DC COM (+24VRTN)
1633
BSD's
1634
Chain 1 Standby Power
1634
1.1 MAIN POWER ON ( t701701a-eln)
1634
1.2A DC POWER DISTRIBUTION (t701702a-eln)
1635
1.2B DC POWER DISTRIBUTION (t701703a-eln)
1636
1.3 POWER INTERLOCK SWITCHING ( t701704a-eln)
1637
1.4 INTERLOCK SWITCHING ( t701705a-eln)
1638
Chain 2 User Interface
1639
2.1 CONTROL PANEL (LEFT) ( t702711a-eln)
1639
2.2 CONTROL PANEL SWITCHES(RIGHT) ( t702712a-eln)
1640
2.3 CONTROL PANEL(LENS) (t702713a-eln)
1641
2.4 LCD CONTROL ( t702714a-eln)
1642
Chain 3 Machine Run Control
1643
3.1 PWBS COMMUNICATION (ESS-IOT, ESS-IIT/IPS) ( t703721a-eln)
1643
3.2 PWBS COMMUNICATION(ESS-UI) ( t703722a-eln)
1644
3.3 PWBS COMMUNICATION (OPTION:IOT-TRAY MODULE, IOT-DUPLEX) (t703723a-eln)
1645
3.4 PWBS COMMUNICATION (OPTION:IOT-FINISHER) ( t703724a-eln)
1646
3.5 PWBS COMMUNICATION (IIT/IPS-DADF) ( t703725a-eln)
1647
3.6 ELECTRIC BILLING (t703726a-eln)
1648
3.7 Accessory Foreign Interface
1649
Chain 4 Start Print Power
1650
4.1A FUSER DRIVE / MAIN DRIVE CONTROL (t704731a-eln)
1650
4.1B FUSER DRIVE / MAIN DRIVE (t704732a-eln)
1651
4.2A DRUM / IBT AUGER DRIVE CONTROL (Motor Control) (t704733a-eln)
1652
4.2B DRUM / IBT AUGER DRIVE CONTROL (Motor Control) (t704734a-eln)
1653
4.2C DRUM / IBT AUGER DRIVE CONTROL (Clutch Control) (t704735a-eln)
1654
4.2D DRUM / IBT AUGER DRIVE CONTROL (t704736a-eln)
1655
4.3A DEVELOPER DRIVE CONTROL (t704737a-eln)
1656
4.3B DEVELOPER DRIVE CONTROL (t704738a-eln)
1657
Chain 5 Document Transportation
1658
5.1 DOCUMENT SIZE SENSING (t705741a-eln)
1658
5.2 DOCUMENT SETTING ( t705742a-eln)
1659
5.3 DOCUMENT FEED AND TRANSPORTATION (1 OF 2) ( j0st90503)
1660
5.4 DOCUMENT FEED AND TRANSPORTATION (2 OF 2) (t705744a-eln)
1661
5.5 DOCUMENT FEED AND TRANSPORT MECHANISN (t705745a-eln)
1662
5.6 DOCUMENT EXIT TRANSPORTATION ( t705746a-eln)
1663
Chain 6 Imaging
1664
6.1 PLATEN DOCUMENT SETTING ( t706751a-eln)
1664
6.2 IMAGE INPUT ( t706752a-eln)
1665
6.3 CARRIAGE SCAN (t706753a-eln)
1666
6.4 LASER CONTROL AND SCANING (t706754a-eln)
1667
6.5 ROS MOTOR CONTROL ( t706755a-eln)
1668
Chain 7 Paper Supply
1669
7.1 TRAY 1 PAPER SIZE SENSING ( t707761a-eln)
1669
7.3 TRAY 2 PAPER SIZE SENSING (t707763a-eln)
1670
7.4 TRAY 3 PAPER SIZE SENSING ( t707764a-eln)
1671
7.5 TRAY 2 PAPER SIZE SENSING (OPTION:TANDEM TRAY MODULE) ( t707765a-eln)
1672
7.6 TRAY 3 PAPER SIZE SENSING (OPTION:TANDEM TRAY MODULE) (t707766a-eln)
1673
7.7 TRAY 1 PAPER STACKING (t707767a-eln)
1674
7.9 TRAY 2 PAPER STACKING (OPTION:2TRAY MODULE) (t707769a-eln)
1675
7.10 TRAY 3 PAPER STACKING (OPTION:2TRAY MODULE) (t707770a-eln)
1676
7.11 TRAY 2 PAPER STACKING (OPTION:TANDEM TRAY MODULE) (t707771a-eln)
1677
7.12 TRAY 3 PAPER STACKING (OPTION:TANDEM TRAY MODULE) (t707772a-eln)
1678
7.13 MPT PAPER STACKING (OPTION:MPT) ( t707773a-eln)
1679
Chain 8 Paper Feed and Transportation
1680
8.1 TRAY1-4 AND MPT PAPER FEEDING ( t708781a-eln)
1680
8.2 TRAY2 TRANSPORTATION (t708782a-eln)
1681
8.3 2TRAY MODULE TRANSPORTATION (OPTION:2TRAY MODULE) ( t708783a-eln)
1682
8.4 2TRAY MODULE PAPER TRANSPORT DRIVE CONTROL (2TRAY MODULE OPTION) ( t708784a-eln)
1683
8.5 TANDEM TRAY MODULE TRANSPORTATION (OPTION:TANDEM TRAY MODULE) (t708785a-eln)
1684
8.6 TANDEM TRAY MODULE PAPER TRANSPORT DRIVE CONTROL (OPTION:TANDEM TRAY MODULE) (t708786a-eln)
1685
8.7 REGISTRATION (t708787a-eln)
1686
Chain 9 Xerographics
1687
9.1 CRU LIFE CONTROL ( t709791a-eln)
1687
9.2 CHARGING AND EXPOSURE (t709798a-eln)
1688
9.3 DEVELOPER HOUSING/TONER CARTRIDGE POSITIONING (t709795a-eln)
1689
9.4A DEVELOPMENT AND TONER DISPENSE CONTROL (t709799a-eln)
1690
9.4B DEVELOPMENT AND TONER DISPENSE CONTROL ( T709793a-eln)
1691
9.5 FIRST IMAGE TRANSFER ( t709794a-eln)
1692
9.6 PR DRUM CLEANING (t709800a-eln)
1693
9.7 SECOND IMAGE TRANSFER AND STRIPPING (t709796a-eln)
1694
9.8 IBT CLEANING (t709797a-eln)
1695
9.9 WASTE TONER REMOVAL (t709801a-eln)
1696
Chain 10 Copy Transportation and Fusing
1697
10.1 UNFUSED PRINT ( t710808a-eln)
1697
10.2 FUSING HEAT CONTROL ( t710801a-eln)
1698
10.3 FUSING ( t710802a-eln)
1699
10.4 EXIT TRANSPORTATION ( t710803a-eln)
1700
10.5EXIT TRANSPORTATION MECHANISM ( t710804a-eln)
1701
10.6 DUPLEX (OPTION:DUPLEX) ( t710805a-eln)
1702
10.7 OFFSET CONTROL (EXIT2) ( t710807a-eln)
1703
Chain 12 Finishing
1704
12.1 FINISHER DC POWER AND INTERLOCK SWITCHING ( t712811a-eln)
1704
12.2 HORIZONTAL TRANSPORTATION ( t712812a-eln)
1705
12.3 FINISHER TRANSPOETATION ( t712813a-eln)
1706
12.4 TAMPING AND OFFSET ( t712814a-eln)
1707
12.5 STAPLE POSITIONING (t712815a-eln)
1708
12.6 STAPLE CONTROL ( t712816a-eln)
1709
12.7 SET EJECT ( t712817a-eln)
1710
12.8 STACKER TRAY CONTROL (1 OF 2) ( t712818a-eln)
1711
12.9 STACKER TRAY CONTROL (2 OF 2) ( t712819a-eln)
1712
Chain 13 Nohad
1713
Chain 13 Nohad
1713
Chain 15 A-Finisher
1716
CH15.1 A-Finisher DC Power and Interlock Switching
1716
CH15.2 PWBS Communication (IOT-A-Finisher)
1717
CH15.3 A-Finisher Transportation
1718
CH15.4 Tamping and Offset
1719
CH15.5 Staple Control
1720
CH15.6 Set Eject (1 OF 2)
1721
CH15.7 Set Eject (2 OF 2)
1722
CH15.8 Stacker Tray Control
1723
Chain 16 Printer
1714
Chain 16 Printer
1714
Chain 17 FAX
1715
Chain 17 FAX
1715
8 Options and Accessories
1724
8.1 Fax Kit
1726
8.2 Foreign Interface
1726
Other manuals for Xerox WorkCentre 7132
Service Manual
27 pages
User Guide
468 pages
System Administration Guide
184 pages
Supplementary Guide
3 pages
Quick Network Setup Guide
73 pages
Setup Guide
10 pages
Paper Guide
2 pages
Evaluator Guide
24 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Xerox WorkCentre 7132 and is the answer not in the manual?
Ask a question
Xerox WorkCentre 7132 Specifications
General
Brand
Xerox
Model
WorkCentre 7132
Category
All in One Printer
Language
English
Related product manuals
Xerox WORKCENTRE 7120
234 pages
Xerox WorkCentre 7125
236 pages
Xerox WorkCentre 7345
128 pages
Xerox WorkCentre 7556
70 pages
Xerox WorkCentre 7830
83 pages
Xerox WorkCentre 7545
70 pages
Xerox WorkCentre 7845
83 pages
Xerox WorkCentre 7242
236 pages
Xerox WorkCentre 7535
70 pages
Xerox WorkCentre 7220
302 pages
Xerox WorkCentre 7970
316 pages
Xerox WorkCentre 7225
302 pages